1997 Toyota 4Runner Structure

THE FRAME SNAPPED FROM RUST AS I WAS DRIVING

THE FRAME ON MY 4RUNNER IS RUSTING ALONG THE REAR AXLE CONTROL ARM MOUNT (THE PIECE WELDED TO THE FRAME THAT YOU CAN SEE WHEN CROUCHED DOWN LOOKING UNDER THE REAR DOORS). THIS SEPARATES AND CAUSES THE REAR AXLE TO FLOAT AROUND WHICH MAY CAUSE A VERY SERIOUS ACCIDENT. I HAVE SEEN COUNTLESS OTHER INCIDENTS WHERE PEOPLE HAVE HAD THIS SEPARATE COMPLETELY WHILE ON THE HIGHWAY AND THEY WERE BARELY ABLE TO MAINTAIN CONTROL OF THE VEHICLE.

1997 TOYOTA 4RUNNER "REAR FRAME RUST AND HOLES" MY TOYOTA 1997 4RUNNER (CURRENT MILEAGE 139,035) HAS THE RUST AND HOLES ON THE REAR PASSENGER SIDE & DRIVER SIDE FRAMES. TOYOTA SERVICE CENTER MECHANIC SAID " DO NOT DRIVE BECAUSE IT IS VERY DANGEROUS." I BOUGHT THIS CAR AT $34,500 ON JUNE 1997. IT WAS VERY EXPENSIVE ONE. IT'S VERY RIDICULOUS THAT THIS EXPENSIVE CAR HAS THIS KINDS OF PROBLEM. LET ME HAVE RECALL SERVICE. I WILL APPRECIATE FOR YOUR COMMENTS. THANK YOU.

FRAME IS COMPLETELY ROTTED VEHICLE WELL KEPT AND IT JUST KEEPS ROTTING SO I DO NOT KNOW WHAT TO DO BUT I WAS DRIVING ON THE HIGHWAY AND THEY TRAILER ARM BROKE OFF THE TRUCK ALMOST CAUSING ME TO WRECK.

TL* THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 45 MPH, THE REAR OF THE VEHICLE STARTED SWAYING LEFT AND RIGHT. THE CONTACT WAS ABLE TO DRIVE HOME. UPON PARKING THE VEHICLE, THE CONTACT INSPECTED UNDERNEATH AND FOUND RUST ON THE REAR DRIVER SIDE FRAME. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT FOUND RECALLS FOR OTHER TOYOTA VEHICLES FOR FRAME RUST, BUT NOT FOR THE 4RUNNER. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000. *TT *TR

EXTENSIVE RUST , FRAME WILL NOT PASS INSPECTION.

MY 1997 4RUNNER ONLY HAS 116,XXX MILES AND ITS FRAME IS STARTING TO ROT. MAKING IT DANGEROUS TO DRIVE AND IT'S ALSO ON OTHER 4RUNNERS. I GUESS IT HAPPENED OVER THE YEARS BUT IT IS NEAR THE BACK BY THE REAR PART OF THE FRAME.

I AM THE ONLY OWNER OF THIS 1997 TOYOTA WHICH I'VE PLANNED TO KEEP FOR EVER. HOWEVER, THIS WEEKEND WHILE REPLACING A SHOCK ABSORBER I FOUND THAT THE FRAME, BY THE MUFFLER HAS RUSTED THROUGH, THE GASH IS APPROXIMATELY 18 INCHES LONG. THERE ARE OTHER AREAS FAR BEYOND WHAT CAN BE CONSIDERED NORMAL RUST DUE TO AGING. THE DAMAGE LOOKS UNSAFE. I FOUND THE DAMAGE ON THE BELOW STATED DATE BUT THIS KIND OF DAMAGE MUST TO HAVE TAKEN YEARS.

GOING DOWN ROAD AT 50MPH CAR LET LOOSE VERY HARD TO HANDLE PULLED ME INTO BURM OF ROAD SWAYING BACK AND FOURTH. HAD CAR TAKEN TO BE INSPECTED FRAME BROKE LOOSE TOTALLY ROTTED FROM INSIDE OUT LOOKS LIKE COOKIE CRUMBLES. FRAME HAS ALWAYS BEEN TAKEN CARE OF AS THIS IS 22ND 4RUNNER OWNED WITH SAME PROBLEM THIS TIME ALMOST SEVERE ACCIDENT. CONTACTING A LAWYER AS THIS ISSUE IS BEING NEGLECTED RESEARCH DONE AND THIS IS VERY COMMON IN 4RUNNERS AND A VERY GOOD CLASS ACTION LAW SUIT.

TL* THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS CORRODED ON THE REAR DRIVER SIDE. THE VEHICLE WAS TAKEN TO A BODY REPAIR SHOP, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.

RE: 1997 TOYOTA 4RUNNER - I AM ORIGINAL OWNER OF THIS DEFECTIVE VEHICLE.THE FRAME RAIL ON THE PASSENGER SIDE HAS SEVERE RUST PERFORATION IN THE BACK WHERE THE REAR CONTROL ARM BRACKET IS WELDED TO THE FRAME RAIL. AN INDEPENDENT CERTIFIED MECHANIC HAS STATED THAT THE VEHICLE IS UNSAFE TO DRIVE AND SHOULD HAVE BEEN RECALLED AS THIS IS A MANUFACTURER DESIGN/MATERIAL DEFECT AND A COMMON ISSUE ALTHOUGH PREVIOUSLY UNKNOWN TO ME. UPON FURTHER RESEARCH I HAVE LEARNED THAT MANY OTHER OWNERS OF THIS GENERATION OF THETOYOTA 4RUNNER HAVE REPORTED THIS ISSUE. PLEASE NOTE THERE A GREAT MANY OF THESE VEHICLES STILL IN SERVICE WHOSE OWNERS ARE UNAWARE OF THIS ISSUE AND ARE IN SERIOUS DANGER OF HARMING THEMSELVES AND OTHER INNOCENT PEOPLE. MUST THE NHTSA WAIT FOR SOMEONE TO DIE BEFORE TOYOTA IS HELD ACCOUNTABLE BY THE NHTSA FOR THIS DEFECT?

TL* THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. WHEN THE VEHICLE WAS TAKEN TO HAVE THE TIRES REPLACED, THE TECHNICIAN NOTICED THAT THE FRAME OF THE VEHICLE WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

DRIVE DOWN THE ROAD AND THE PART FROM REAR END THAT CONNECTS TO FRAME RUSTED AND BROKE OFF. VIOLENT SHAKING OCCURRED AND FORCED ME OFF THE ROAD. FRAME LOOKS GOOD EVERYWHERE ELSE BUT THE SAME LOCATION ON BOTH SIDE.

TL* THE CONTACT OWNS A 1997 TOYOTA 4 RUNNER. THE CONTACT STATED THAT THE REAR FRAME FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 261,909. THE VIN WAS NOT AVAILABLE.

CARS REAL END STARTED TO SWAY WHEN DRIVING, TOOK IT TO THE MECHANICS AND WAS TOLD THE FRAME WAS RUSTED THROUGH, THAT IT WAS UNSAFE TO DRIVE. CONTACTED TOYOTA AND WAS TOLD NO RECALL ISSUED,NOTHING THEY COULD DO!!!!. THIS TOYOTA ONLY HAS 121,000 MILES ON IT!! IT SHOULD BE GOING FOR ANOTHER 100,000, THAT'S WHY PEOPLE BUY TOYOTAS!! MY SON BOUGHT THIS CAR 3 YEARS AGO, TOOK ALL HIS MONEY NOW HE HAS NO CAR TO DRIVE OR MONEY TO BUY A NEW ONE. TOYOTA SHOULD ISSUE A RECALL. SINCE THIS HAPPENED I FOUND THAT MANY OTHER TOYOTA 4RUNNER OWNERS HAVE THIS SAME ISSUE. THEY RECALLED THE TACOMA FOR THE SAME REASON.. SAME YEARS. NEED A RECALL ON THE 4RUNNER!!! *TR

PURCHASED WITH 165,000 MILES. ALMOST NEW FOR A MODERN VEHICLE. TOOK IT TO THE MECHANIC AND WAS NOTIFIED THE FRAME WAS RUSTED OUT, THE REAR END WAS READY TO COLLAPSE, AND IT WAS UNSAFE TO DRIVE. TOOK IT TO A BODY SHOP FOR A SECOND OPINION AND NOTIFIED THE SAME THING. TOYOTA MANUFACTURER CUSTOMER SUPPORT LINE CONTACTED AND NOTIFIED ME THERE IS NO RECALL ON THIS VEHICLE FOR THIS. THIS VEHICLE WAS REGISTERED ITS ENTIRE LIFE IN KENTUCKY, NOT MICHIGAN. RUSTING OUT AT 165K IS UNHEARD OF FOR A MODERN VEHICLE IN THESE CONDITIONS. DEEPLY DISAPPOINTED IN TOYOTA FOR NOT STANDING BEHIND THEIR PRODUCT. I WILL PROBABLY HAVE TO SELL IT TO THE JUNKYARD. WHAT A WASTE OF MONEY I DON'T HAVE.

THE FRAME HAS PREMATURELY RUSTED THROUGH IN FRONT OF THE RIGHT, REAR TRAILING ARM. MY SHOP TELLS ME THE FRAME IS TOO RUSTED TO REPAIR IT. *TR

RUST. THE FRAME HAS ALMOST COMPLETELY RUSTED THROUGH, AS HAS THE REAR FENDER. 1997 TOYOTA 4RUNNER WITH MAJOR RUST ISSUES. *TR

ORIGINAL OWNER, BOUGHT NEW. KEPT VEHICLE VERY WELL MAINTAINED WITH REGULAR INSPECTIONS ON A LIFT AND NO EVIDENCE OF FRAME RUST OR OTHER PROBLEMS. THEN ON ABOVE DATE AN INSPECTION SHOWED MANY SPOTS OF RUST ON THE FRAME - IT HAD BEEN ROTTING FROM THE INSIDE OUT. MULTIPLE BODY EXPERTS SAID IT WAS TOO FAR GONE TO REPAIR AND NOT SAFE TO DRIVE. FORTUNATELY IT DID NOT FAIL WHEN MY FAMILY AND I WERE ON THE HIGHWAY, POTENTIALLY KILLING US AND ANYONE AROUND US. TOYOTA CUSTOMER "EXPERIENCE" REPS REFUSED EVEN TO ACKNOWLEDGE A PROBLEM - AND I ESCALATED THIS AS FAR AS I COULD. THEY HAD NO ANSWER FOR WHY THEY BOUGHT BACK TACOMAS, TUNDRAS AND SEQUOIAS (WHICH HAVE THE SAME FRAME) BUT DID NOT EVEN ISSUE A MAINTENANCE ADVISORY FOR THE 4RUNNERS. IF THEY WON'T PAY ATTENTION TO THIS, THE GOVERNMENT SHOULD FORCE A RECALL. THE REST OF THESE VEHICLES ARE BUILT WELL AND THE FRAME MAY WELL FAIL FIRST, WHICH NO ONE EXPECTS. *TR

TL-THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. THE CONTACT STATED AS HE REPLACED THE FRONT TIE ROD HE NOTICED THE REAR SUBFRAME AREA AND THE REAR LOWER CONTROL ARM WERE SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WERE 144,216. RK

FOUND CLUNKING SOUND FROM FRONT OF VEHICLE AND FOUND CHASSIS RUSTED THROUGH IN SEVERAL PLACES. TOYOTA DEALERSHIP CONTACTED AND SAID VEHICLE NOT AFFECTED BY ANY WARRANTY OR RECALL. *TR

TL* THE CONTACT OWNS 1997 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN CONFIRMED THE FAILURE AND STATED THAT THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 175,000. *TR

DRIVING ON HIGHWAY CLOSE TO HOME WHEN VEHICLE SUDDENLY STARTED SWAYING. PULLED OVER AND BEGAN TO DRIVE SLOWLY ON SIDE OF ROAD, NO TRAFFIC, TIL I GOT HOME. SHOP OWNER SAID FRAME BROKE ON THE REAR DRIVER SIDE. TRUCK IN GREAT SHAPE, NOBODY EVER GAVE ME AN INDICATION SOMETHING WAS WRONG UNDERNEATH THE VEHICLE. I COULD HAVE POSSIBLY CRASHED IF GOING FASTER AND MORE TRAFFIC, I WAS VERY LUCKY. *TR

TL* THE CONTACT OWNS A 1997 TOYOTA 4 RUNNER. THE CONTACT WAS TRAVELING 20 MPH AND NOTICED AN ABNORMAL NOISE FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS INSPECTED BY A LOCAL MECHANIC AND THE CONTACT WAS TOLD THAT THE PASSENGER'S SIDE REAR SWAY BAR OF SUB FRAME WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 189,500. ...UPDATED 11-18-13 *BF

I HAVE HAD MY 4RUNNER FOR SEVERAL YEARS AND HAVE ALWAYS LOVED MY TRUCK AND AS OF LAST YEAR THE FRAME HAS BEEN SO RUSTED THEY WON'T PUT IT ON A LIFT NEVER MIND INSPECT IT..I DON'T UNDERSTAND WHY THE TACOMA TUNDRA AND SEQUOIA HAVE ALL BEEN RECALLED FOR THIS ISSUE AND NOT MY RUNNER ..I'VE TALKED TO MANY PEOPLE WITH THE SAME ISSUE ..CAN SOMEONE PLEASE HELP ME. *TR