1997 Toyota 4Runner SUSPENSION,STRUCTURE

FRAME RUST MAKES VEHICLE DANGEROUS WHILE DRIVING.

TL* THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. WHILE REVERSING OUT OF THE DRIVEWAY, THE VEHICLE SWAYED BACK AND FORTH. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT EXITED THE VEHICLE AND NOTICED THAT THE FRAME WAS RUSTED AND THERE WAS NOTHING SUPPORTING THE STABILIZER ARM. FOX TOYOTA (228 FOX FAMILY LN, CLINTON, TN 37716, (865)-494-0228) WAS CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 271,000.

THE FRAME WAS POORLY DESIGNED AND NOT ENOUGH RUST PROTECTION WAS APPLIED BY TOYOTA. WE RARELY GET SNOW AND STILL THE VEHICLE HAS RUSTED THROUGH. TOYOTA DID NOT MAKE A DRAIN HOLE SO THAT THE WATER IN THE FRAME WOULD EVAPORATE. THERE ARE A LOT OF THESE VEHICLES WHICH OTHERWISE LAST A LONG TIME. A LOT OF OWNERS HAVE 4RUNENRS WITH EXCELLENT ENGINE/TRANSMISSION BUT WITH RUSTED FRAMES. THIS IS A DISASTER WAITING TO HAPPEN ON UNSUSPECTING OWNERS.

TO WHOM IT MAY CONCERN: THANK YOU FOR YOUR IMMEDIATE ATTENTION TO THIS CONCERN. I JUST PURCHASED A 1997 TOYOTA 4RUNNER WITH 173,000 MILES ON IT. I WAS MADE AWARE BEFORE BUYING THE VEHICLE THAT THERE IS SOME RUST UNDERNEATH AND SO I EXAMINED THE PROBLEM AND DETERMINED THAT IT IS NOT MAJOR AND IS REPAIRABLE. AFTER PURCHASING THE VEHICLE, I FOUND THAT THE PROBLEM IS QUITE LARGER THAN I INITIALLY ASSESSED. I REALIZE THAT THIS MAKES ME RESPONSIBLE FOR A BAD DECISION BUT I ALSO THINK THAT IT IS IMPORTANT FOR THE SAFETY OF THE GENERAL PUBLIC TO BRING THESE RUST ISSUES TO THE ATTENTION OF THE NHTSA WITH THE HOPE THAT ENOUGH COMPLAINTS WILL AFFECT A RESPONSE THAT WILL HOLD THE MANUFACTURER RESPONSIBLE. I REALIZE THAT THIS VEHICLE IS 15 YEARS OLD AND HAS HIGH MILEAGE BUT AT THE SAME TIME, I DON'T BELIEVE THAT THE ROTTING FRAME IS AN ACCEPTABLE DEFECT IN AN 18 YEAR OLD VEHICLE THAT WAS CLEARLY VERY WELL MAINTAINED BY IT'S ORIGINAL OWNER, AND BY THE NUMBER OF SUBMITTED AND UNSUBMITTED COMPLAINTS, THIS IS A COMMON PROBLEM WITH THIS PARTICULAR VEHICLE WHICH POINTS TO A DEFECT IN MANUFACTURING. IN ADDITION, THIS ROTTING FRAME PROBLEM MUST HAVE STARTED WHEN THE VEHICLE WAS MUCH YOUNGER BECAUSE THE FRAME IS ROTTED THROUGH IN TWO PLACES AND IT DOESN'T TAKE A SCIENTIST TO KNOW THAT THIS KIND OF DAMAGE TAKES TIME. THE MAIN FRAME ON MY 4RUNNER IS ROTTED COMPLETELY THROUGH IN FRONT OF AND BEHIND THE LEFT REAR WHEEL. I CANNOT DRIVE THE VEHICLE THAT I JUST BOUGHT BECAUSE OF THE SAFETY CONCERNS AND I'M CONCERNED THAT THERE ARE LESS MECHANICALLY INCLINED PERSONS OUT THERE WHO ARE UNAWARE OF THIS ISSUE AND UNKNOWINGLY PUTTING THEMSELVES AND THE GENERAL PUBLIC AT RISK. PLEASE TAKE IMMEDIATE ACTION TO HOLD THE MANUFACTURER ACCOUNTABLE FOR THIS DEFECT. THANK YOU. *TR

TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE SWAYED FROM LEFT TO RIGHT AND BECAME HARD TO CONTROL. THE CONTACT STATED THAT AFTER THE VEHICLE WAS PARKED, IT WAS DISCOVERED THAT THE REAR PASSENGER SIDE BRACKET THAT HOLDS THE STABILIZER BAR TO THE FRAME WAS FRACTURED. IN ADDITION, THE CONTACT NOTICED THAT THE WHOLE REAR FRAME WAS RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 263,514.

THE FRAME IS COMPLETELY RUSTED THREW IN MULTIPLE PARTS OF THE FRAME. SOMEONE HAS ALREADY TRIED WELDING SOME PLATING TO KEEP REAR SUSPENSION COMPONENTS OF THE LOWER FOUR LINK ATTACHED TO THE FRAME. EXTREMELY UNSAFE. *TR

EXTENSIVE RUST ON FRAME AROUND WELD OF THE CONTROL ARM OF THE REAR DRIVER'S SIDE WHEEL. THIS CAUSED THE CONTROL ARM TO DETACH MAKING THE VEHICLE UNSAFE TO DRIVE. IT APPEARS THERE ARE QUITE A FEW COMPLAINTS ABOUT FRAME RUSTING FOR TOYOTA 4RUNNERS. *TR

I HEARD A NOISE TOWARD THE REAR OF THE VEHICLE, SO I TOOK IT TO THE GARAGE TO HAVE IT CHECKED. THEY INFORMED ME THAT THE LEFT REAR FRAME WAS COMPLETELY RUSTED INTO AND THE FRAME ON THE RIGHT SIDE WAS ALMOST AS BAD. I WAS TOLD TO TAKE IT HOME AND PARK IT BEFORE A BAD ACCIDENT HAPPENED. *TR

1997 TOYOTA 4 RUNNER FRAME ROT AND RUST: I NOTICED RUST DEBRIS IN MY DRIVEWAY. I INSPECTED UNDER THE VEHICLE AND FOUND THAT THE INSIDE OF DRIVER-SIDE FRAME WAS COMPLETELY ROTTED WITH EXTENSIVE RUST ALONG ENTIRE LENGTH OF ADJACENT FUEL TANK. HOLES LARGE ENOUGH TO PUT FOUR FINGERS IN AND CRUMBLE. IT IS CLEAR THAT THE ROT HAS ALMOST GONE ENTIRELY THROUGH THE FRAME AS THERE ARE SEVERAL SMALL HOLES ON OUTSIDE OF FRAME AS WELL. THE RUST HAS ALSO SERIOUSLY COMPROMISED THE WELD SEAM ON THE SUSPENSION COMPONENT ATTACHED TO THE FRAME. RUST AND ROT OF THIS SEVERITY ON THIS VEHICLE IS ISOLATED ONLY TO THIS AREA OF THE FRAME. THE REST OF VEHICLE FRAME SHOWS TYPICAL SURFACE RUST AS EXPECTED WITH AGE OF VEHICLE. *TR

HAVING COMPLAINED ABOUT A CLUNKING NOISE IN THE REAR OF THE VEHICLE FOR QUITE SOME TIME TO THE TOYOTA DEALER, I WAS SOLD A NUMBER OF REPAIRS OVER THE LAST 15,000 MILES, INCLUDING REAR STABILIZER LINKS AND REAR SHOCKS. HOWEVER, THE NOISE PERSISTED. AFTER SPENDING HUNDREDS AND HUNDREDS OF DOLLARS ON REPAIRS, I HAVE NOW DISCOVERED THE REAR DRIVERS SIDE PORTION OF THE FRAME IN THE AREA UNDER THE REAR SEAT HAS TOTALLY ROTTED AWAY AND THE LOWER REAR CONTROL ARM WELDMENT IS NO LONGER ATTACHED TO THE FRAME, LEAVING THE VEHICLE UNSTABLE (SWAYING SIDE TO SIDE) AND UNSAFE. THE DEALERSHIP NEVER ADVISED ME OF ANY PROBLEM, LEADING ME TO SPEND THE MONEY ON THESE OTHER REPAIRS. THIS FRAME DESIGN HAS BEEN RECOGNIZED AS A PROBLEM BY TOYOTA A FEW YEARS BACK. TOYOTA PROVIDED RELIEF FOR THE SAME ISSUE ON THE TACOMA. OBVIOUSLY THE 4RUNNER SUFFERS THE SAME PROBLEM AND SHOULD BE EVALUATED AS THIS IS A VERY SERIOUS SAFETY ISSUE. *TR

RUSTED FRAME..... UNSAFE SAFE TO DRIVE. *TR

THIS 1997 TOYOTA 4RUNNER HAS PREMATURE STRUCTURAL FRAME FAILURE. THE FRAME IS ROTTING FROM THE INSIDE OUT. THE FRAME ROT IS LOCATED IN THE REAR ON THE DRIVERS SIDE WHERE THE REAR SUSPENSION BRACKET IS WELDED TO THE FRAME. THIS IS AN EPIDEMIC AMONG OLDER TOYOTA TRUCKS AND SUV'S. TOYOTA HAS ALREADY RECALLED THE TACOMA'S OF THIS MODEL YEAR DUE TO THE FRAMES ROTTING. I HAVE READ COUNTLESS NUMBERS OF COMPLAINTS ON THE INTERNET FROM OTHER 4RUNNER OWNERS. IT IS TIME TO PUSH TOYOTA TO HELP ALL OF THE OWNERS OF THESE TOYOTA'S OUT. *TR

TL* THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE WOULD SWAY FROM LEFT TO RIGHT. THE VEHICLE WAS TOWED TO THE DEALER AND THEY ADVISED HIM THAT THE FRAME WAS RUSTED AND THE SUSPENSION COMPONENTS WERE FRACTURED FROM THE FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 150,000. UPDATED 09/27/11 *BF

WHILE DRIVING AT HIGHWAY SPEEDS IN THE SNOW, VEHICLE LOST DIRECTIONAL STABILITY AND SPUN OUT OF CONTROL, CAUSING A ROLL OVER. VEHICLE WAS TOTALLED. CONSUMER HAS JUST RECEIVED A RECALL NOTICE FOR REAR SUSPENSION.*AK. THERE WERE 2 INJURIES.*JB