2024 Toyota Corolla Steering

DEFECT: Steering wheel fails to fully return to center after turns, consistently stopping 1/2-1 inch off-center. Minor steering adjustments stick and don't self-correct. Pronounced binding zone near center prevents smooth return. SYMPTOMS: After curves, wheel returns 80% but stops visibly off-center requiring manual correction. Minor lane adjustments stick and require counter-correction. Constant manual steering correction causes driver fatigue. Progressive worsening since purchase. SAFETY: Incomplete return at highway speeds causes drift. Sticking divides attention from hazards. Emergency maneuvers require manual straightening during critical response time. SERVICE: February 2026 - McGovern Toyota technician documented "VEHICLE DID NOT RETURN OR SELF CENTER" but Toyota corporate refused repair claiming "normal characteristic." Had 6+ alignments with no improvement. Recent alignment caused binding to flip sides, proving internal mechanical binding not alignment issue. RELATED: Toyota issued CSP 22TE02/TSB T-SB-0028-22 (2022) for 2018 Camry with identical "reduced return to center" caused by intermediate shaft binding. My 2024 Corolla has same defect Toyota acknowledged in 2018 models but refuses to repair. INDUSTRY PATTERN: Honda HR-V TSB 24-094 (2024), Mazda CX-90 Recall 24V-022 (26+ failed fix complaints, 2 crashes), GM Bolt TSB 17-NA-148, Ford Explorer ST owner reports - all for steering not returning to center. REQUEST: Investigate if Toyota intermediate shaft defect extends to 2024 Corolla and whether industry-wide EPS binding represents systemic safety issue. Toyota confirmed defect in writing but denies repair.

Vehicle Information: * Make: Toyota * Model: Corolla Hybrid AWD * Model Year: 2024 * Current Mileage: [14,000] * Mileage When Problem Noticed: ~8,000-9,000 miles Incident Description: My 2024 Toyota Corolla Hybrid AWD has a severe steering defect. After a right turn, the steering wheel consistently fails to return to center, remaining 5-15 degrees (up to 20 for sharp turns) off-center to the right. It does not self-correct. Occasionally, this also occurs after left turns, but less frequently. The vehicle requires constant, active manual correction to stay straight. If I release the wheel, the car can drift right, posing a significant collision risk. The steering feels "floaty" and lacks the expected resistance to return to center. This issue began abruptly around 8,000-9,000 miles. Multiple dealership visits and alignment checks have not resolved it. No prior accidents or modifications. The Lane Tracing Assist (LTA) system functions smoothly, keeping the car centered. However, immediately after disengaging LTA, the manual steering defect reappears, indicating an underlying mechanical problem, not an electronic one. Safety Concern: This defect creates a serious safety hazard. It demands constant driver attention and effort, leading to distraction and fatigue. This compromises directional stability and significantly increases accident risk, as the car will veer off course if not continuously corrected. I urge NHTSA to investigate this defect. Similar "sticky steering" or "poor return to center" issues are reported in other modern vehicles, and Toyota itself issued CSP 22TE02 for a related "slower to return to center" issue in 2018 Camry models, proving this is a known type of defect, not normal operation.

My [XXX] daughter's 2024 Toyota Corolla stopped in the middle of the road and would not move. She received a message that said, "engine stopped steering power low". She called me in a panic and could not move the car out of traffic. I asked her to turn the car off and back on and it resolved the issue. This could cause a traffic fatality with loss of control of a car in traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

while I am driving on a highway the steering tries to turn right while i am driving. there a ditches on the right on the highway my car is not safe to drive it is putting me and my family in danger. I took my car to the dealership twice they said my car is fine.