2004 Toyota Highlander Power Train

TRANSMISSION JUMPS AT DIFFERENT SPEEDS. *TR

SINCE I PURCHASED MY 2004 TOYOTA HIGHLANDER V6 IT HAS VERY ROUGH SHIFTS. THE TRANSMISSIONS SEEMS TO HESITATE AND LAG WHEN I TRY TO ACCELERATE DURING NORMAL DRIVING SPEEDS, (I FEEL LIKE I AM ON A CARNIVAL RIDE). I HAVE HAD IT TO 3 DIFFERENT DEALERSHIP IN FLORIDA & THEY ALL SAY THE SAME THING ("THAT THIS MODEL DRIVES LIKE THAT" & IT'S THE WAY YOU DRIVE") FUNNY THOUGH WHEN THE MECHANIC DROVE IT, WITH ME IN THE CAR HE SAID THAT IT WAS THE TRANSMISSION. THE UNDERWRITERS IN SERVICE THINK BECAUSE I'M A WOMEN, IT'S THE WAY I DRIVE. I LOVE MY CAR BUT, THIS PROBLEM NEEDS TO BE ADDRESSED BY TOYOTA & FIXED !!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!! *JS

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE SMELL OF BURNING OIL WAS EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE TRANSMISSION OIL BEARING SEAL NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 85,250. UPDATED 08/08/2012 *JS

HESITATION DURING AUTO TRANSMISSION GEAR CHANGES. ENGINE REVS VERY HIGH THEN CHANGES GEARS. *TR

CAR HESITATES AND SUDDENLY SURGES FORWARD. THE IS THE 2ND TIME THIS HAS OCCURRED IN THE PAST 3 MONTHS. THE FIRST TIME WAS NEAR MY GARAGE AND FORTUNATELY THE CAR ONLY TRAVELED SEVERAL FEET FORWARD BEFORE HITTING THE CORNER OF THE GARAGE AND COMING TO A STOP. LAST SUNDAY, I WAS LEAVING A PARKING LOT. I WAS TURNING LEFT WHEN THE CAR HESITATED AND SUDDENLY SURGED FORWARD AT A RAPID SPEED. BEFORE I WAS ABLE TO REGAIN CONTROL, THE CAR HAD TRAVELED APPROXIMATELY 20-25 FEET FORWARD, RAN UP ON A MEDIAN AND CRASHED INTO A TREE. I CALLED THE POLICE ABOUT FILING A REPORT BUT AS IT OCCURRED ON PRIVATE PROPERTY, THEY DECLINED. *TR

TOYOTA HIGHLANDER 2004 6 CYL AWD - LAST MAY SQUEALING NOISE COMING FROM BACK OF THE CAR. MADE IT TO A TOYOTA DEALER AND FOUND OUT IT WAS THE REAR DIFFERENTIAL. TOOK 4 DAYS AND OVER $1200 TO FIX. THIS WEEK, NOISE COMING FROM FRONT OF THE CAR. CONTINUED TO GET WORSE. TOOK TO TOYOTA DEALER AND WAS INFORMED IT WAS THE DRIVE SHAFT - SO FAR OUT OF ALIGNMENT NEEDS TO BE REPLACED? JUST HAD IT AT THE SAME DEALER FOR MAINTENANCE 3 WEEKS AGO - SAID NOTHING. THIS WILL COST $1300. SEARCHING INTERNET AND FINDING I'M NOT ALONE, BUT NO RECALL. WHAT GIVES WITH THESE CARS? *TR

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH AND DEPRESSING THE ACCELERATOR, THE VEHICLE WAS HESITANT TO RESPOND. THE FAILURE WOULD OCCUR MOST PROMINENTLY WHEN THE VEHICLE WAS FIRST STARTED. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 91,000 AND CURRENT MILEAGE IS 93,000.

MY 2004 TOYOTA HIGHLANDER LIMITED V6 DEVELOPED SUBSTANTIAL TRANSMISSION/ TRANSAXLE LEAK AT 56,000 MILES. TRANSMISSION FLUID WAS ABLE TO LEAK INTO THE FRONT TRANSAXLES AND THEN ONTO THE GROUND. TOYOTA IS AWARE THAT THE #2 AXEL SEAL IS AT FAULT AS IT IS WELL REPORTED. THE REPAIR WAS OVER $2,000. I FIXED MINE, BUT AM CONCERNED ABOUT THOSE THAT WON'T BE FIXED. I AM CONCERNED THAT IF THE TRANSMISSION LEAKS OUT IN TOTAL WOULD THE RESULTING TRANSMISSION FAILURE RESULT IN INJURY.*TW

HAVE A 2004 TOYOTA 3.3L 2WD HIGHLANDER THAT HAS HAD A SURGING PROBLEM WHEN TAKING OFF FROM A START SINCE I HAD IT NEW....DEALER RECALIBRATED COMPUTER BUT DIDNT FIX THE PROBLEM....THEY TOLD ME THIS IS NORMAL.....IT IS NOT NORMAL AND IS VERY DANGEROUS....BEING THEY DONT WANT TO FIX IT, I GUESS IT WILL COME DOWN TO A LAW SUIT IF SOMETHING HAPPENS.....THERE ARE ALL KINDS OF POST ON THIS PROBLEM AND TOYOTA SHOULD BE RECALLING AND FIXING......WONT NEVER BUY TOYOTA AGAIN IF SOMETHING ISNT DONE BECAUSE THEY STILL SEEM TO BE HAVING THIS PROBLEM IN OTHER MAKES AND MODELS IN TOYOTA LINE....AND LEXUS........*CN

MY 2004 TOYOTA HIGHLANDER V6 AT TIME HAS VERY ROUGH SHIFTS. THE TRANSMISSIONS SEEMS TO HESITATE AND LAG WHEN I TRY TO ACCELERATE DURING NORMAL DRIVING SPEEDS. THIS HAS HAPPENED WHEN I WAS GOING 20 TO 60. *TR

S10 APPROPRIATE HANDLING RE COMPLAINT AGAINST TOYOTA MOTOR CORPORATION AND JAY WOLFE TOYOTA OF WEST COUNTY FM OWNER OF A 2004 TOYOTA HIGHLANDER. *TGW AFTER DRIVING THE VEHICLE FOR A FEW WEEKS, IT BECAME APPARENT THERE WAS A PROBLEM WITH THE SHIFTING WITH THE AUTOMATIC TRANSMISSION. THE CONDITION WAS MOST NOTICEABLE DURING SHARP ACCELERATION PERIODS. THE ENGINE WOULD REV UP, BUT IT DID NOT GAIN SPEED RELATIVE TO THE AMOUNT OF PRESSURE APPLIED TO THE ACCELERATOR. THE ENGINE WOULD SOUND AS IF IT WAS UNDER STRESS AND IT WOULD THEN SHIFT WITH A SEVERE JOLT. THE DEALER INFORMED THE CONSUMER TOYOTA WAS AWARE OF THE TRANSMISSION FLAW, BUT THERE WAS NO FIX. THE CONSUMER HAS SINCE TRADED THE VEHICLE.

2004 TOYOTA HIGHLANDER V6 - AUTO (2WD) SINCE WE'VE PURCHASED THE T-HIGHLANDER, THE CAR WILL OCCASIONALLY SUDDENLY JERK FORWARD UNCONTROLLABLY WHEN SHIFTING FROM 2ND TO 3RD GEAR AND WHEN THE SHIFT TAKES PLACE BETWEEN 2,000 AND 2,500 RPM WHEN IN 2ND GEAR. WE HAVE BROUGHT THIS IN TO THE TOYOTA DEALERSHIP ON NUMEROUS OCCASIONS ONLY TO BE TOLD THIS IS A "PROGRAMMING" ISSUE AND THE CAR IS TRYING TO FIGURE OUT HOW TO SHIFT BASED ON DIFFERENT DRIVERS. I'VE LOOKED ONLINE AND ON FORUMS AND OTHER OWNERS HAVE THE SAME PROBLEMS. I THINK IT'S TOYOTA TRYING TO SAVE $$. MY CONCERN SINCE WE'VE BROUGHT THE CAR IN TO THE TOYOTA DEALERSHIPS IS THE SAME CONCERN THAT I WANT THE NHTSA TO BE AWARE OF NOW AND THAT IS, THERE IS A PROBLEM WITH THE CAR AND THERE IS A POTENTIAL FOR AN ACCIDENT HERE DUE TO SOMETHING THAT IS CLEARLY DEFECTIVE WITH THE TRANSMISSION AND/OR THE "PROGRAMMING" OF HOW THE COMPUTER SHIFTS. THIS COMPLAINT IS BEING FILED BECAUSE ALL OF THE OTHER TOYOTA PROBLEMS THAT HAVE SURFACED HAVE REAFFIRMED WHAT I'VE KNOWN ALL ALONG, THAT THERE ARE PROBLEMS WITH TOYOTAS AND IN OUR CASE, NOT HAVING COMPLETE CONTROL OF THE VEHICLE WHEN DRIVING. HOWEVER, I WAS MADE TO FEEL THAT I HAD NO BASIS FOR MY COMPLAINTS WHEN IN FACT, I DO. I HOPE THAT EVEN IF NOTHING IS DONE TO FIX MY T-HIGHLANDER AS I HAVE GIVEN UP ON IT (SHORT OF LEGAL ACTION, WHICH MIGHT BE WORTHWHILE NOW) THAT THE NHTSA DOES DO SOMETHING TO ENSURE THAT NO ONE IS INJURED AS A RESULT OF THIS "PROGRAMMING" ISSUE. *TR

I HAVE A 2004 TOYOTA HIGHLANDER WITH APPROXIMATELY 70K MILES. FOR THE SECOND TIME THE WHEEL BEARINGS HAVE FAILED ON THE VEHICLE. I SPOKE WITH TOYOTA AND THEY DO NOT BELIEVE IT IS A SAFETY ISSUE EVEN THOUGH THIS IS A KNOW ISSUE (ALL OVER THE WEB). I BELIEVE ANYTHING RELATED TO THE DRIVABLE/STEERING IS A SAFETY ISSUE AND TOYOTA SHOULD FURTHER INVESTIGATE THE FAILURES. *TR

TRANSFER ASSY FAILED AT 74,000 MILES AND FAILED AGAIN AT 101,000 MILES. *TR

ACCELERATION LAGS ALL THE TIME, BUT IS ESPECIALLY APPARENT WHEN "FLOORING IT" UPON FREEWAY ENTRY, PASSING, ETC. I SEE THAT THIS IS ONE OF THE MOST FREQUENT COMPLAINTS ABOUT 04 HIGHLANDERS. OVERALL, QUITE DISAPPOINTED IN MY OVERPRICED SUV. *TR

2004 TOYOTA HIGHLANDER WITH AWD AND 4 CYL. VEHICLE IS LEAKING TRANSMISSION FLUID AT 67,500 MILES. DEALERSHIP SAY THAT TOYOTA WILL NOT HELP WITH THIS PROBLEM AS IT AS THE WARRANTY EXPIRED AT 60,000 MILES. I BOUGHT THIS VEHICLE DUE TO THE EXPECTED RELIABILITY OF A TOYOTA PRODUCT, BUT IT APPEARS THAT TOYOTA DOES NOT STAND BEHIND THEIR PRODUCT. MY OTHER VEHICLE IS A LEXUS RX 300 WHICH I LOVE, BUT I WILL BE HARD PRESSED TO BUY ANOTHER TOYOTA PRODUCT IN THE FUTURE AFTER THIS EXPERIENCE. *TR

TRANSMISSION FLUID LEAKING FROM DIFFERENTIAL - 2000 MILES OUT OF WARRANTY - DEALER SAID THEY HAVE AT LEAST TWO OTHER VEHICLES THAT HAVE HAD SIMILAR PROBLEMS THIS VEHICLE IS A 2004 TOYOTA HIGHLANDER. *NM

I HAVE A 2004 TOYOTA HIGHLANDER WITH A 3.3L V6 AUTOMATIC TRANSMISSION. WITHIN THE FIRST WEEK OF DRIVING THE VEHICLE THAT WAS PURCHASED NEW FROM THE MANUFACTURER, I NOTICED THAT THE TRANSMISSION SEEMED TO HESITATE WHEN ACCELERATING AT LOW SPEEDS. THE PROBLEM PERSISTED AND I TOOK THE VEHICLE IN FOR SERVICE. THE DEALER SAID THEY COULD NOT REPRODUCE THE PROBLEM OR FIND ANYTHING WRONG. NOW THE CAR HAS ALMOST 20,000 MILES ON IT, I'VE TAKEN THE CAR BACK TO THE DEALER A FEW TIMES AS THE HESITATION HAS GOTTEN WORSE AND THEY CONTINUE TO TELL ME THERE IS NOTHING WRONG WITH THE CAR. I RARELY DRIVE THE CAR NOW SINCE I HAVE COME VERY CLOSE TO HAVING A MAJOR ACCIDENTS NUMEROUS TIMES. IN EACH CASE, I WILL TRY AND MERGE ONTO A FREEWAY. GOING UP THE RAMP (OR DOWN) AND ACCELERATING TO GET UP TO SPEED, THE TRANSMISSION WILL DELAY FOR 2-3 SECONDS. I THEN PUSH THE GAS PEDAL DOWN A BIT MORE AND THE RPM'S WILL SHOOT UP, THE CAR WILL JERK, AND SPEED AHEAD. IF I DON'T APPLY THE EXTRA GAS, IT LEAVES ME IN A SITUATION WHERE I MIGHT BE HIT FROM BEHIND BY OTHER CARS. WHEN THE CAR JERKS AHEAD, I'VE COME CLOSE TO SLAMMING INTO CARS AHEAD OF ME. I'VE DONE SOME RESEARCH ON THE WEB AND HAVE FOUND NUMEROUS OTHER TOYOTA OWNERS WITH THIS SAME EXACT PROBLEM. I HOPE NO ONE HAS BEEN KILLED OR INJURED FROM THIS DEFECT THAT TOYOTA IS UNWILLING TO ADDRESS, AND THAT THE NHTSA WILL INVESTIGATE THIS BEFORE ANYONE IS KILLED OR INJURED. *NM

TRANSMISSION SHIFT HESITATION ON ACCELERATION AT LOWER SPEEDS. JUST ENOUGH LAG TIME TO SCARE ME A FEW TIMES THAT I WOULDN'T MAKE IT ACROSS TRAFFIC. *JB

ENGINE HESITATION WHEN ACCELERATING FROM LOW SPEEDS; TRANSMISSION SHIFTS HARD AT LOW SPEEDS CAUSING THE VEHICLE TO HESITATE AND THEN SURGE WHEN ACCELERATING. *NM

2004 TOYOTA HIGHLANDER AUTOMATIC TRANSMISSION HAD EXPERIENCED A DANGEROUS HESITATION WHILE TRYING TO DOWNSHIFT. *MR *SC

MY 2004 TOYOTA HIGHLANDER V6 (3.3L WITH 5-SPEED TRANSMISSION) HAS AN INTERMITTENT FAULT WHERE THE AUTOMATIC TRANSMISSION WILL ABRUBTLY DROP DOWN A GEAR (OR GEARS) WHILE SIMULTANEOUSLY TRYING TO ACCELERATE CREATING A SENSATION LIKE IT IS BUCKING OR PORPOUSING. USUALL STEPPING OFF OF THE ACCELERATOR IS SUFFICIENT TO ELIMINATE THE BUCKING SENSATION. THIS HAS OCCURED SINCE I PURCHASED THE VEHICLE NEW IN AUGUST 2004.

WE PURCHASED A 2004 V6/5 SPEED AUTO 2WD TOYOTA HIGHLANDER IN JUNE, 04. IT HAS A HESITATION PROBLEM WHICH CREATES A SAFETY HAZARD. IT LOSES POWER FOR SEVERAL SECONDS AFTER DECELERATING AND RE- ACCELERATING TO CHANGE LANES OR MAKE LEFT TURNS, THEREBY EXPOSING A POWERLESS, DECELERATING CAR TO ONCOMING TRAFFIC. HAVE TAKEN THE CAR TO THE DEALER TWICE. THEY CLAIM IT IS A DESIGN PROBLEM, THEY CANNOT FIX. THEY SAY IT OCCURS AS A RESULT OF THE ADAPTIVE LEARNING ALGORITHM IN THE ENGINE/TRANSMISSION PACKAGE. CHECK THE EDMONDS TOWN HALL BY SEARCHING FOR "HESITATION" AND YOU'LL FIND IT REPORTED SINCE 12/03 BY HIGHLANDER, CAMRY, SOLARA, LEXUS RX330 AND LEXUS CAMRY EQUIVALENT OWNERS ALL HAVING GOTTEN NO COMMITMENT BY TOYOTA TO FIX IT. THIS IS A SAFETY HAZARD AS DESCRIBED BY THE CLASSICAL DEFINITIONS. IT OCCURS FREQUENTLY (IN MOST VEHICLES AND IN NORMAL OPERATION, AND MORE THAN A FEW OF THE OCCURRENCES WILL EXPOSE THE OCCUPANTS TO SEVERE PERSONAL INJURY. TOYOTA CLAIMS THE HESITATION IS "NORMAL" BECAUSE ALL THE HIGHLANDERS ON THE LOT DO IT--WHICH ONLY REINFORCES THE HIGH FREQUENCY ESTIMATE. FOR WHATEVER REASON, THEY ARE NOT ADDRESSING THIS ISSUE WITH ANYTHING OTHER THAN AN OFFER TO HAVE A TOYOTA REP CONFIRM YOUR CAR HAS IT AND THEN TO TAKE THE ISSUE TO ARBITRATION. ITS TIME FOR YOU TO INVESTIGATE, BEFORE SERIOUS INJURIES OR DEATHS OCCUR. IF WE CAN BE OF ASSISTANCE, PLEASE DO NOT HESITATE TO CONTACT ME. JIM MULLEN. *AK *JB

AT APPRX. 13000 MILES ON A 2004 TOYOTA HIGHLANDER, NOTICED INCREASINGLY ROUGH SHIFTING FROM THE AUTOMATIC TRANSMISSION. VEHICLE OFTEN HESITATES WHEN SHIFTING, THEN SURGES INTO NEXT GEAR, CAUSING UNPREDICTABLE RIDE. THROUGHOUT THE GEARS, VEHICLE SEEMS TO BE HUNTING FOR GEARS, UPSHIFTING & DOWNSHIFTING AT ODD TIMES, CAUSING A ROUGH, UNPREDICTABLE RIDE. TOOK IT BACK TO THE DEALER AND THEY 'RECALIBRATED' THE TRANMISSION, HOWEVER, THIS DIDN'T SEEM TO RECTIFY THE PROBLEM.

AT 12 MONTHS AND 13,000 MILES, NOTICED 2004 TOYOTA HIGHLANDER TO HAVE TRANSMISSION PROBLEMS. DURING SHIFTING, TRANSMISSION OFTEN HESITATES AND THEN SUDDENLY SURGES INTO NEXT GEAR, CAUSING INABILITY TO PREDICT VEHICLE PERFORMANCE. THROUGHOUT DRIVING, TRANSMISSION FEELS LIKE ITS HUNTING FOR GEARS, FREQUENTLY SHIFTING AT ODD TIMES, CAUSING A ROUGH, UNPREDICTABLE RIDE.