2004 Toyota Highlander Steering

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE REQUIRED GREATER EFFORT TO STEER. WHILE STEERING THE VEHICLE, THERE WAS AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WERE IT WAS DIAGNOSED THAT THE STEERING INTERMEDIATE STAFF ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 123,000.

WITH NO WARNING OR PRIOR INDICATION OF ANY PROBLEM, THE STEERING RACK AND PINION BROKE MAKING THE VEHICLE COMPLETELY UN-STEERABLE. TOYOTA REPAIR FOUND THAT THE POWER STEERING PUMP BELT WAS BROKEN AND THE PUMP HAD LOCKED UP. THE VEHICLE WAS BEING DRIVEN ON A FREEWAY THROUGH THE MOUNTAINS AND IT WAS JUST FORTUNATE THAT THE INCIDENT OCCURRED ON ONE OF THE FEW STRAIGHT STRETCHES AND IT WAS POSSIBLE TO KEEP THE VEHICLE ON THE ROAD SURFACE. *TR

THE STEERING ANGLE SENSOR WENT ON RANDOMLY DURING DRIVING, THE TRACTION CONTROL INDICATOR LIGHT WAS ON, CAUSING ENGINE SPEED SLOW DOWN AND SLUGGISH ON ROAD, IT HAPPENED A FEW TIMES. I DROVE SLOWLY TO THE DEALER, IT COSTS OVER $600.00 TO FIX THE PROBLEM, I AM VERY DISAPPOINTED AT TOYOTA. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED WHEN THE ENGINE WAS STARTED THE STEERING ANGLE SENSOR WARNING LIGHT ILLUMINATED AND THE STEERING BECAME DIFFICULT TO HANDLE. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT WAS UNABLE TO LOCATE A FAILURE. THE VEHICLE WAS TEST DRIVEN AND THE FAILURE WAS RECREATED. THE DEALER REPLACED THE STEERING ANGLE SENSOR. THE FAILURE AND THE CURRENT MILEAGE WAS 14,000. UPDATED 5/2/11 *CN

2004 HIGHLANDER - STEERING FAILED ON MAJOR SHOPPING ROAD TODAY. HEARD ONLY A HISSING SOUND IN THE ENGINE COMPARTMENT WITH A LARGE PLUME OF DARK SMOKE OUT THE TAIL PIPE. ENGINE DID NOT QUIT BUT WAS LUCKY TO BE ABLE TO PULL WHEEL HARD RIGHT TO TURN INTO PARKING LOT. AI/C STAYED ON, DID NOT OVERHEAT, TIMING BELT JUST CHANGED, NO LEAKING FLUIDS BUT MOST OF ALL NO WARNING LIGHTS OR CHECK ENGINE LITE CAME ON. HAD PROBLEM LAST MONTH WITH A/C WHICH WAS FIXED. WHAT HAPPENS TO SOMEONE DRIVING AT 65 ON HIGHWAY AND LOSES ABILITY TO STEER ... INSTANT DEATH TO DRIVER AND PERHAPS MANY OTHERS. BEEN A TOYOTA FAN FOR 30 YEARS BUT THIS COUPLED WITH OTHER MAJOR RECALLS SERIOUSLY FRIGHTENS ME TO GET BEHIND THE WHEEL AGAIN. CAR WAS TOWED TO TOYOTA DEALER WHO HAS MAINTAINED THE CAR SINCE 2004. AWAITING OUTCOME OF INVESTIGATION. POSTED 8-9-10. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE DRIVING AT SPEEDS OF 5 MPH AND ATTEMPTING A TURN, THE CONTACT HEARD AN UNUSUAL CLANKING NOISE COMING FROM THE STEERING WHEEL. THE DEALER WAS UNABLE TO DUPLICATE OR DETERMINE WHERE THE NOISE HAD COME FROM. THE CONTACT STATED THE NOISE WAS HEARD ONE ADDITIONAL TIME. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 32,000 AND THE CURRENT WAS 44,000.

"INTERMEDIATE SHAFT FAILURES ON 04-05 TOYOTA HIGHLANDER" THERE IS A TECHNICAL SERVICE BULLETIN (ST001-06) OF SHAFT REPLACEMENT ON SOME MODELS BUT NEVER BECAME A SAFETY RECALL ISSUE. ON TOYOTA PRIUS NHW20 MODEL VEHICLES PRODUCED IN JAPAN FROM JULY 2003 TO NOV 2005 ARE BEING RECALLED. TOYOTA SAYS ON SOME VEHICLE, UNDER CERTAIN CONDITIONS, THE STEERING INTERMEDIATE SHAFT MAY BECOME LOOSE OR DEVELOP A CRACK. WHAT ABOUT THOSE PEOPLE WHO WANTS TO KEEP THEIR TOYOTA FOR A LIFETIME? MINE IS AN SUV(HIGHLANDER) WITH A HIGHER CENTER OF GRAVITY AND ROLLING FORCE. YOUR HELP ON THIS MATTER IS DEEPLY APPRECIATED. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE VEHICLE WAS STATIONARY. THE CONTACT STARTED THE IGNITION AND TURNED THE STEERING WHEEL TO THE LEFT AND THE RIGHT. THE STEERING WHEEL EXHIBITED A SLIGHT VIBRATION AND NOISE. THE FAILURE OCCURRED WHENEVER THE STEERING WHEEL WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE VEHICLE COULD BE DRIVEN AND IF THE FAILURE PROGRESSED TO RETURN IT FOR REPAIR. THE FAILURE MILEAGE WAS 45,000. UPDATED 4/22/10 *CN UPDATED 06/01/10*JB

STEERING WHEEL MAKE A NOISE LIKE A BOLT IS MISSING. *TR

STEERING. LOOSENESS WHEN TURNING LEFT OR RIGHT. DEALER REPLACED PART (45220-48150 SHAFT ASSY) @ A COST OF $387.93 (THIS WITH A 15% DISCOUNT). IN READING YOUR COMPLAINTS FILED, I NOTE THIS WASN'T T/1ST TIME THIS HAS BEEN REPORTED & AS STATED, THERE IS A DEALER SERVICE ADVISORY ON IT. I ALSO TOOK NOTE THAT THERE APPARENTLY HASN'T BEEN ANY ACTION 2 RESOLVE THE MATTER (IE, THE OWNER CONTINUES 2 PAY 4 REPAIRS). SHOULD NOT TOYOTA B REQUIRED 2 COVER THIS TYPE OF REPAIR ? LIKE WE'RE TALKING STEERING HERE. IS IT GOING TO TAKE SOMEONE WHO JUST LET'S THE PROBLEM GO TO THE POINT WHERE HE/SHE LOOSES CONTROL OF THE VEHICLE & THERE IS PHYSICAL INJURY OR DEATH? I WAS HESITANT TO WRITE THIS UP BECAUSE I DON'T SEE WHERE N INVESTIGATION HAS BEEN CONDUCTED (DID I JUST MISS IT?). MY VEHICLE HAS JUST UNDER 55K MILES ON IT (ALL OF THEM ONROAD) &S BEEN MAINTAINED BY THE DEALER. TO ME IT LOOKS LIKE A $$$ MAKER 4 THE DEALER & A CALCULATED DECISION BY TOYOTA THAT ENOUGH OF THOSE REQUIRING THE REPAIR WOULDN'T COMPLAIN; LOOKS LIKE TOYOTA WINS. *TR

HEARD A CLICKING SOUND WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT. *TR

AFTER STARTING MY CAR AND DRIVING IT TWO BLOCKS, THE VSC LIGHT AND AUDIBLE WARNING BUZZER WENT ON AT THE SAME TIME MY CAR LOST TRACKING AND STARTED VEERING TO THE LEFT. I WAS ABLE TO GET THE CAR HOME, BUT THE SAME THING HAPPENED AS SOON AS I DROVE IT 3 BLOCKS TO A SERVICE STATION. DIAGNOSTICS DISCOVERED THE STEERING ANGLE SENSOR WAS DEFECTIVE. THE PART WAS REPLACED FOR $630.11. I SEE THIS AS EXTREMELY DANGEROUS AS IT COULD HAVE POTENTIALLY RESULTED IN A CAR ACCIDENT. *TR

2004 TOYOTA HIGHLANDER LIMITED STEERING SYSTEM LOOSENESS, CLUNKING. THE STEERING SYSTEM EXHIBITS EXCESSIVE FREEPLAY AND CLUNKING. A DEFECTIVE PART WAS REPLACED UNDER WARRANTY BUT NEEDS TO BE REPLACED AGAIN. THE VEHICLE HAS LESS THAN 30,000 MILES ON IT. *TR

WHILE DRIVING ON BUSY HIGHWAY THE STEERING OF MY TOYOTA BECAME IMPOSSIBLE I MANAGED TO GET CAR OFF OF ROAD . HAD VEHICLE TOWED TO GARAGE THE STEERING ANGLE SENSOR HAD GONE BAD THE MECHANIC ADVISED ME THAT THIS WAS A DANGEROUS SITUATION. I WAS ALSO INFORMED THAT THERE HAD BEEN A TECHNICAL SERVICE BULLETIN SENT OUT ON THIS SITUATION. I JUST FEEL THAT THE OWNERS NEED TO BE AWARE OF THIS SITUATION AND TOYOTA SHOULD TAKE SOME RESPONSIBILITY FOR THIS DANGEROUS DEFAULT. *TR

HIGHLANDER RECENTLY RECEIVED 30K SERVICE AT TOYOTA DEALER. CAR MILEAGE WAS APPROXIMATELY 29K. THE SERVICE ADVISOR REPORTED THAT THE INTERMEDIATE SHAFT IN THE STEERING COLUMN WAS MAKING A CLUNK TYPE SOUND AND SHOULD BE REPLACED. HE BELIEVED HIGHLANDERS AND TACOMA'S HAD BEEN HAVING A PROBLEM. HE DID NOT THINK THE PART WOULD BREAK BUT THAT THE PART HAD BEEN REDESIGNED AND WILL NEED TO BE REPLACED. *TR

I NOTICED A CLUNKING NOISE AND "SENSATION" IN THE STEERING WHEEL WHEN TRAVELING AT A SLOW SPEED ESPECIALLY WHEN TURNING CORNERS OR ON A BUMPY ROAD. IN DECEMBER, 2007 I TOOK THE HIGHLANDER TO THE DEALER AND WAS FIRST TOLD THAT IT WAS NOT A PROBLEM AND JUST NEEDED SOME LUBRICATION. WHEN I QUESTIONED THE SERVICE MANAGER FURTHER ABOUT THE POSSIBILITY OF IT BEING DANGEROUS, I WAS TOLD THAT IT "COULD BE A PROBLEM AND THAT THE STEERING SHAFT SHOULD BE CHANGED". I WAS TOLD THAT THE COLUMN COULD "LOCK UP", CAUSING LOSS OF STEERING. AFTER FURTHER QUESTIONING, THE DEALERSHIP GAVE ME A COPY OF THE TOYOTA TECHNICAL SERVICE BULLETIN DATED FEBRUARY 2006, OBVIOUSLY TOYOTA WAS WELL AWARE OF THE POSSIBLE DANGER, I WAS ALSO TOLD THAT IT WAS NOT AN UNUSUAL PROBLEM. THEY WOULD FIX THE PROBLEM AT A COST OF $450 TO ME SINCE THE CAR WAS NO LONGER UNDER WARRANTY. MY WARRANTY EXPIRED IN MAY OF 2007, ALMOST A YEAR AFTER THE TECHNICAL SERVICE BULLETIN WAS ISSUED. IT APPEARS THAT TOYOTA PURPOSELY HAS NOT ISSUED A RECALL IN ORDER TO SAVE MONEY. THOSE OF US WHO OWN A 2004 HIGHLANDER ARE NOW OUT OF WARRANTY AND OUT OF LUCK. SINCE THIS IS A POTENTIAL DANGER AND TOYOTA WAS AWARE OF THE PROBLEM FOR WELL OVER A YEAR, I BELIEVE THAT TOYOTA SHOULD BE RESPONSIBLE FOR ALL NEEDED REPAIRS AND A RECALL ISSUED. *TR

BOUT MY 2004 HIGHLANDER 3 MONTHS AGO, USED, WITH 46K MILES ON IT. I TOOK IT TO MY MECHANIC LAST WEEK TO GET THE OIL CHANGED AND TIRES ROTATED. HE TOOK IT FOR A DRIVE AND SAID THAT IT WON'T PASS INSPECTION IN 3 MONTHS BECAUSE OF THE STEERING. THERE IS A CLUNK IN THE STEERING, WHICH I NEVER THOUGHT WAS ABNORMAL BUT HE SAID IT IS. HE ALSO SAID THERE IS A SERVICE BULLETIN OUT ON IT. I CALLED THE DEALER AND MADE AN APPOINTMENT FOR NEXT WEEK. I SERIOUSLY HAD BETTER NOT HAVE TO PAY FOR THIS. *TR

2004 TOYOTA HIGHLANDER BRAKES ENGAGED WHEN ACCELERATOR WAS DEPRESSED. CUSTOMER STATES THAT HE WAS IN A PARKING LOT HIT THE ACCELERATOR AND THE BRAKES APPLIED, AND THAT MADE THE ENGINE STALL. HE WAS UNABLE TO START THE VEHICLE. *KB THE DEALER FOUND THE STEERING ANGEL SENSOR WAS NOT OUT PUTTING CORRECTLY WHICH CAUSED THE VSC TO ACTIVATE. *JB

STEERING. *TR

STEERING SHAFT ON THE 2004 TOYOTA HIGHLANDER DID NOT FEEL SAFE, FELT LOOSE AND NOISY WHEN TURNING. TOYOTA REFUSESD TO FIX THE PROBLEM UNDER WARRANTY, A TSB WAS ISSUED IN JANUARY 2006, WHICH INDICATED TOYOTA'S AWARENESS OF THE PROBLEM, BUT DID NOT WANT TO PUBLICLY ADMIT IT. WHILE DRIVING IT FELT LIKE THE STEERING COLUMN COUD BREAK OFF, AND IF THAT HAPPENED, IT COULD HAVE CAUSED MANY DEATHS.*AK

I BOUGHT USED 2004 TOYOTA HIGHLANDER AND NOTICED A HEARD A THUMPING SOUND THAT COULD ALSO BE FELT IN THE STEERING WHEN TURNING THE STEERING WHEEL AT SLOW SPEEDS. HAD AN ACCIDENT A FEW MONTHS LATER, WHERE ANOTHER VEHICLE HIT MY FRONT LEFT WHEEL. THE THUMPING GOT WORSE SO I MENTIONED IT TO THE BODY REPAIR SHOP. THEY HAD IT TOWED TO A TOYOTA DEALER EVEN THOUGH I HAD DRIVEN IT FOR 6 WEEKS AFTER THE ACCIDENT, WHERE THEY WERE TOLD THAT IT WAS NORMAL WEAR , 85,000 MILE,) ON THE INTERMEDIATE STEERING SHAFT, AND IT NEEDED TO BE REPLACED AT A COST OF $380 +. THE DEALER SERVICE DEPARTMENT SAID IT WAS NOT ACCIDENT RELATED. I STILL HAVE NOT HAD IT REPAIRED. *AK

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHEN MAKING A LEFT TURN THE CONTACT HEARD A CLICKING NOISE NEAR THE STEERING COLUMN. THE CONTACT STATED THAT UNDER NORMAL DRIVING CONDITIONS THE VEHICLE SWERVED WHILE DRIVING FORWARD. THE DEALER REPLACED THE STEERING SHAFT AND THE CLICKING STOPPED, HOWEVER, THE SWERVING CONTINUED. THE DEALER STATED THAT THE POWER STEERING RACK NEEDED TO BE REPLACED. THE CURRENT MILEAGE IS 46,000 , AND FAILURE MILEAGE WAS 41,000. *AK

LOOSE AND NOISY STEERING SHAFT, DOES NOT FEEL SAFE TO DRIVE. *JB

NOISY STEERING SHAFT CAUSED ME TO TAKE CAR TO DEALERSHIP, WHERE I WAS TOLD THE SHAFT WAS 'WORN' (TINY BEARINGS WITHIN THE SHAFT WERE WORN) AND THE SHAFT WAS REPLACED. DEALER INFORMED ME THEY'D SEEN THIS PROBLEM ON OTHER TOYOTA HIGHLANDERS, AND ON THEIR ECONOMY TOYOTA PRISMS AS WELL, BUT MANUFACTURER HAD NOT ISSUED ANY RECALLS. I PAID THE BILL USING MY EXTENDED WARRANTY.*AK

2004 TOYOTA HIGHLANDER BEGAN MAKING A NOISE WHICH COULD BE FELT IN THE STEERING WHEEL, PARTICULARLY WHEN TURNING OR GOING OVER A BUMP AT SLOW SPEED. TOYOTA HAS A TSB OUT ON THIS BUT IT IS NOT KNOW TO OWNERS, AND IS NOT WELL KNOW AT THE DEALERSHIP. THIS DESPITE HUNDREDS IF NOT THOUSANDS OF COMPLAINTS ON THE WEB. FURTHERMORE, TOYOTA REPS AND THE DEALER'S SERVICE WRITERS WILL TELL YOU FACE TO FACE IT IS NOT A SAFETY ISSUE, BUT WON'T PUT IT IN WRITING. WHEN THE PROBLEM WAS FINALLY REPAIRED BY REPLACEMENT OF THE STEERING SHAFT, I BECAME AWARE THAT PRIOR TO THE REPAIRS THE CAR WAS PULLING TO THE LEFT AND THE STEERING WHEEL WAS HARD TO TURN AS THE VEHICLE NOW TRACK STRAIGHT AND THE WHEEL EASY TO TURN. WITH SUCH SYMPTOMS I FEEL VERY STRONGLY THAT TOYOTA SHOULD BE COMPELLED TO NOTIFY VEHICLE OWNERS. *NM