2007 Toyota Tacoma Structure

I have a well cared for, garaged 2007 Tacoma. It had a recall for a known frame corrosion issue. I had it inspected by Toyota and they chose not to replace the frame, choosing instead to apply a CRC spray in 2016. I have learned that my vehicle was sprayed by a formula that was later known to Toyota to harbor water and accelerate rusting. My vehicle has just failed state inspection and was identified to have a cracked frame in two places. Both left and right sides of the frame, behind the cab, and directly across from one another. The fact that Toyota now chooses not to honor any warranties, or provide consumer help, (I just spoke with their "Brand Engagement Center"), when I am the recipient of 2 known and compounding failures seems a dereliction of responsibility. I have a vehicle that should have a lot of service life left but for inadequate steel being used in production, that was then given an inadequate remedy which was later discontinued by Toyota after being found to accelerate corrosion. This seems like an obvious case of manufacturer responsibility but I'm being told I'll receive no assistance from the Toyota corporation. I wonder whether the inspection done in the first place was adequately and responsibly performed.

The frame has been rusting real bad and seen other Tacomas same year and style have the recall. Especially rusting where the running boards were attached too

Despite dealer treatment of the frame in 2014 and an inspection in 2017 the frame rusted through and snapped where the bed meets the cab.

These vehicles have frame rot. It was addressed in cold weather states with a recall but the recall was not available in California. My vehicle was a california only truck. The corrosion if undressed will result in the frame breaking in half behind the rear left passenger seat. Toyota should have included all states in this recall and there are an abundance of toyotas manufactured from 2005 to 2010 on the road with this issue that are ticking time bombs. My vehicle only has 145K miles on it.

My Tacoma has a frame rust issue. I have been told that Toyota did a "voluntary recall" and replaced rusty frames under warranty but that program has ended. This is terrible because it wasn't in an official NHTSA recall, so a Carfax says nothing of 5his issue. I contacted Toyota and they are unwilling to do anything. I have been told that my frame can break in half while driving When reading about this issue, it seems like Toyota did not replace all frames. Instead, there was some way based on the state you lived in as to if you could get a frame replaced. My truck was titled in California. Can someone please help me to get Toyota to repurchase the vehicle from me, allow me to trade it in on a new truck, or replace the frame in the same way they had done so in the past? Thank you.

Frame corrosion safety card never been reported to us by mail, I stop by the dealer and they say is expired the recall. I reported to toyota springfield VA. they say this recall is close back in 2019 and they not be able to fixed. corrosion is extremely serious!

I bought this tacoma last year to someone who don’t do the chasis recall and I like to know if any possible way to do it. this chasis it’s in a very bad condition let me know what I can do thanks

As part of the Tacoma Frame Replacement program (ZH6 and H0F), I brought my Tacoma to my Toyota dealer. They deemed my frame to NOT qualify for the replacement and lazily applied corrosion resistant spray to the rust on the frame that quickly flaked off. As soon as the program ended, the frame deteriorated quickly. There are 3 spots on the frame where my hand can slide through near the front of the frame on both the driver side and the passenger side. I have removed about 5 pounds of frame/rust from the interior of the frame and the exterior of the frame. I have contacted Toyota several times and been told that there are no appeals or anything I can do except pay for a new frame out of pocket, sell, or try to repair.

2007 TOYOTA TACOMA. CONSUMER WRITES IN REGARD TO RUSTED FRAME. THE CONSUMER IS REQUESTING ASSISTANCE WITH A RUSTED FRAME AS THE VEHICLE WILL NOT PASS INSPECTION DUE TO THIS DEFECT.

We bought the truck used in 2021 when it had 114,000 mi. Looked great, drives great. Now our mechanic tells us there are rust spots all over the frame — and that there is a recall. I looked into the recall and the window closed last year. Is it legal for Toyota to stop a recall when it is such a big safety issue? Buyers of used cars need to know about this site to check for recalls. I think very few people know about this app.

The contact owns a 2007 Toyota Tacoma. The contact's husband took the vehicle to a service shop for maintenance and was informed of corrosion to the subframe of the vehicle. The contact took the vehicle to the local dealer, where it was diagnosed with needing the passenger’s side rear frame rail, leaf spring, and several other areas replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 189,000.

Crack on the frame.

The contact owns a 2007 Toyota Tacoma. The contact stated that the passenger's side frame, driver's side frame, and the subframe of the vehicle were severely corroded, including the area where the fuel tank was located. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 14V604000 (Suspension) however, the dealer informed the contact that they could not mount the leaf springs as the frame was severely corroded. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.

in 2020 my mechanic notified me my frame was rusted and would not pass next inspection. i did further research on line and discovered there was a recall of which i never recieved any notification. i also discovered there was a class action lawsuit case # 2:15-cv-02171-fmo-ffm. i contacted toyota and filed a complaint case # 210402000664. they called back saying there was nothing they could do, the frame corrosion warrentee end 8-21-2019. not great news seeing i was not notified of recall or law suit... by the way there are 3 toyotas sitting in my driveway. i have not moved in 20 years , and my phone number has never changed.i have since had the repairs made by replacing the crossmember and patch welding the rusted area at my own expence ( 1000.00$). i have reciepts. there is a lot of life left in my tacoma, i am dissapointed toyota did not help in any way , shape or form....if there is a recall you should stand by your product! i was dismissed to go away and deal with it on my own... so i wish to file a formal complaint against toyota america . im sure there are others out there like me. please help , philip delacruz

The truck frame is rusting away and the dealer said the recall passes in 2016 when it’s supposed to expire 15 years after manufacturing it’s a 2007 Tacoma

The contact owns a 2007 Toyota Tacoma. The contact stated that the chassis was completely rusted, resulting in the vehicle being undrivable. The vehicle was taken to an independent mechanic where it was diagnosed with needing the chassis to be replaced. The manufacturer was informed of the failure and informed the contact that they were unable to assist. The failure mileage was approximately 71,000.

The roof of the truck is rusting and corroding (photo attached). I brought the truck to a reputable body shop, and the technician said that it was clear that the issue was a defective paint job from Toyota, because the corrosion was coming from the body up. I take great care of my truck, including getting it washed and waxed frequently. As you are almost certainly aware, Toyota had a massive recall campaign for Toyota Tacomas because the frames were rusting out. In fact, Toyota replaced the frame of this truck pursuant to that recall. An internet search reveals that countless other Toyota Tacoma owners are experiencing the exact same issue as me, with corrosion on the roofs of their vehicles. This problem appears to be systemic and the fault of Toyota's manufacturing process. I am concerned that this corrosion poses a safety hazard because it is only a matter of time before the corrosion eats away through the body and causes untold damage to critical components of the vehicle. I tried to resolve this issue directly with Toyota, but they refused to repair the faulty paint job. My vehicle is available for inspection upon request. Thank you.

I'VE NOTICED THE THE UNDERCOATING ON THE FRAME IS REALLY STARTING TO DETERIORATE, AND A LOT OF RUST IS HAPPENING,I KNOW FRAME RUST CAN CAUSE PARTS TO SNAP OFF OR CRACK, WHICH WILL REALLY COMPROMISE THE SAFETY FOR MYSELF, MY PASSENGERS AND OTHER MOTORISTS. IT MAY ALSO SIGNIFICANTLY DIMINISH THE TACOMAS ABILITY TO PROTECT MY FAMILY AND I IN A CRASH. I KNOW CERTAIN TOYOTA'S HAVE THIS RECALL ALREADY BECAUSE OF THE DUST MAGNET UNDERCOATING TOYOTA USES. FOR SOME REASON I WAS ONLY ABLE TO LOAD 1 PHOTO, WILL SEND MORE IF NEEDED, I REALLY NEED SOMETHING DONE.

MY TRUCKS HAS A VERY BAD RUSTED FRAME DUE TO A TOYOTA POOR FRAME COAT AND IT WILL NEED TO REPLACE NOT FEELING SAFE DRIVING NOT LETTER WAS SENT OUT DURING THE TIME TO DO THE RECALL OF TOYOTA FRAMES

RUST FRAME

TL* THE CONTACT OWNS A 2007 TOYOTA TACOMA. THE CONTACT STATED THAT THE CHASSIS OF THE VEHICLE WAS EXTREMELY CORRODED. THE VEHICLE WAS TAKEN TO TOYOTA WORLD OF LAKEWOOD (1118 OCEAN AVE RT 88, LAKEWOOD, NJ 08701) WHERE THE CONTACT WAS INFORMED THAT THE CHASSIS WAS GOOD. THE CONTACT STATED THAT HE MENTIONED AN UNKNOWN NHTSA CAMPAIGN TO THE DEALER AND THE DEALER INFORMED THE CONTACT THAT THE RECALL WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD TAKEN THE VEHICLE FOR SERVICE OF THE TRANSMISSION AT AN INDEPENDENT MECHANIC WHERE HE WAS INFORMED THAT THE CHASSIS WAS IN VERY BAD SHAPE AND WAS ADVISED TO TAKE THE VEHICLE BACK TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE WARRANTY WAS EXPIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 87,000.*DT

MY INDIGO BLUE PAINT HAS PEELED OF THE ROOF OF THE CAB PREMATURELY AND WITHOUT ANY DAMAGE I RESEARCHED THE TOYOTA RECALL ON WHITE BLIZZARD PEARL PAINT AND I BELIEVE THIS IS DEFINITELY A SIMILAR DEFECT. THE VEHICLE WAS STATIONARY PLEASE VIEW PICTURES ATTACHED. SINCERELY [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

CLEAR COAT GONE AND PAINT IS PEELING AND FADING ON ALMOST ALL SURFACES

I PURCHASED THIS VEHICLE NEW IN 2007. RECENTLY UPON MY PERIODIC INSPECTION OF THE FRAME I NOTICED ALL THE FRAME WELDS IN THE UPPER FRAME AREA RUSTED AND THE WELDS APPEARED TO BE BREAKING ON THE FRAME. IF THIS IS IN FACT THE CASE THIS VEHICLE IS NO LONGER ROAD WORTHY. THE FRAME OF ANY VEHICLE SHOULD LAST THE ENTIRE LIFE OF THE VEHICLE. THIS VEHICLE HAS 153000 ORIGINAL MILES ON THE ODOMETER.

I PURCHASE A 2007 TOYOTA TACOMA IN JUNE 2015 AT THAT TIME WE WERE TOLD DUE TO RECALL BY TOYOTA, THE FRAME HAD BEEN UNDERCOATED. RECENTLY RESEARCHING THE RECALL INFORMATION, THIS WAS ONE OF THE OPTIONS FOR REPAIR BY TOYOTA RECALL. WHEN WE WENT FOR AN INSPECTION IT FAILED BECAUSE OF RUSTY FRAME....HOW CAN YOU ALLOW RECALLS TO EXPIRE? I KNOW THIS WAS HUGE EXPENSE TO TOYOTA TO REPAIR VEHICLES, BUT I FEEL LIKE A LIFE IS MUCH MORE IMPORTANT THAN A LOSS FOR A COMPANY THAT SHOULD HAVE MANUFACTURED A QUALITY PRODUCT TO BEGIN WITH. MY QUESTION IS, HOW CAN YOU, IN GOOD CONSCIENCE ALLOW RECALLS TO EXPIRE, WHEN CLEARLY ONE OF THE RECALL OPTIONS DID NOT TAKE CARE OF THE PROBLEM? MY SON SPOKE WITH TOYOTA AND THEY COULD CARE LESS. I DO NOT HAVE THE FINANCES TO REPAIR OR BUY A NEW VEHICLE. I KNOW I AM NOT THE ONLY ONE HAVING THIS PROBLEM. IF PART OF THE RECALL/REPAIR PROCESS WOULD DETERIORATE AFTER A FEW YEARS IS THIS REALLY A FIX TO THE PROBLEM? DOESN'T THAT STILL LEAVE A SAFETY ISSUE? I JUST DO NOT BELIEVE THE UNDERCOAT WORKED THE WAY IT SHOULD HAVE AND A NEW RECALL SHOULD BE ISSUED, AS CLEARLY THIS DID NOT STOP THE PROBLEM AND THE ISSUE IS STILL THERE WITH OWNERS OF UNDERCOATED VEHICLES. I PRAY OWNERS ARE AWARE OF THIS AND IT DOES NOT RESULT IN A LOSS OF LIFE OR LIMB. TOO MANY ACCIDENTS ARE HAPPENING FOR NEGLIGENCE OF THE MANUFACTURE. I DO APPLAUD TOYOTA FOR TRYING TO MAKE THE VEHICLES SAFE, BUT THIS INSTANCE AFTER A FEW YEARS, CLEARLY THE UNDERCOATING FAILED TO REPAIR AND MAKE VEHICLE SAFE.