2022 Toyota Tacoma Power Train

Transmission blew at 40200 miles under normal driving conditions going approximately 30/35 mph

Transmission is failing, fluid was black and burnt at 35k miles (dealer did not provide a large enough sample to allow for testing the fluid because I didn't specify the amount I needed), and vehicle is not throwing a CEL or MIL so therefore Toyota says that there is no defect. Fluid change did improve the functioning, but it did not correct the problem. Transmission failures are a known problem on numerous Toyota vehicles using an A series transmission. My vehicle has done this and progressively worsened since it had roughly 500 miles on it. Dealership originally refused to document my complaints in their system and Toyota Customer Care's assistance has been minimal at best. My vehicle suffers from numerous of the same complaints that are listed under the 2024 model Tacoma. Before servicing the transmission fluid the vehicle would occasionally have an extremely hard shift around 55mph that would result in the truck spinning tires on the interstate which shouldn't even be possible. I actually managed to capture a short video of the dash as it was doing this once and even sent it to Toyota but they said if they can't replicate it then it doesn't count. I think there needs to be an investigation into Toyota's transmission issues as well as someone should investigate their programming for MIL/CEL activation parameters as their vehicles are alerting the driver's to a problem until there is a complete and total failure which could leave the driver in an unnecessary and dangerous situation that could possibly be avoided if the driver was informed when the "Fail-safe" features activate instead of when they're unable to compensate. I am unable to load the video through this computer; however, I can upload the video from my phone upon request.

The contact owned a 2022 Toyota Tacoma. The contact stated that while her son was driving at an undisclosed speed, upon reaching his destination, shifting the vehicle into the park position, and exiting, the vehicle began to roll away. The driver was unable to stop the vehicle, and as a result, the vehicle rolled off the roadway, coming to a complete stop at the bottom of a 25-foot embankment. The vehicle's location required specialized recovery, and upon extracting the vehicle, the recovery specialist confirmed that the shifter was shifted into the park position. All air bags were deployed. No warning lights were illuminated. The vehicle was towed to a towed yard and deemed a total loss by the contact's insurance provider. A police report was not filed, and no injuries were reported. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 41,000.

The contact owns a 2022 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, the gear shifter turned hard. The contact also stated that while shifting the gear, she noticed an abnormal sound. The contact stated that no warning lights were illuminated. The vehicle was taken to the dealer. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure millage was unknown.

Transmission pops out of 2nd gear everyday after setting on level ground. I have questioned Toyota about the fluid levels, which they say its a sealed unit and cant be checked. It takes about 20 feet before the transmission rengages. It only happens when the transmission temperature is cold, then does not happen again. This can leave me without any power. Toyota has checked the vehicle twice and cannot duplicate the issue. The issue started shortly after i bought the vehicle.

When stopped on an hill and depressing the throttle lightly the "Hill Assist" disengages and allows the vehicle to roll backwards. The 1st time this occurred I had a trailer in drive and it rolled backwards breaking a taillight in a jack-knife situation. I took the vehicle to my dealership were the vehicle was checked and no problem was found. They refused to replaced the tail light as no problem was found. The 2nd time was in congested traffic moving at a snails pace. On a steep hill stop and start traffic. When I slowly applied throttle the vehicle "Hill Assist" disengaged and the vehicle rolled backwards. Appling more throttle finally caused the transmission to engage. Now knowing how this occurred I was able to recreate again and again. I again took the vehicle to my dealership even taking my salesman and the service technician on test drives showing them the safety concern. I was again told that no problems were found. I then took my wife on a test ride to show her how the vehicle could roll backwards on a hill in stop and go traffic. During this drive once the vehicle not only started to roll backwards but when the throttle was depressed more the vehicle stalled and continued to roll backwards until i moved my foot from the throttle to the brake. As the engine was off additional effort was required in depressing the brake. The steering was also harder to turn. Had I rolled an additional 12 feet I would have backed into a retaining wall on the passenger side. My wife has decided to take a different routes to avoid hills that have stop and go traffic. I called Toyota filed case # 220407001182 which they declined to repair the taillight and told me that the vehicle operated as designed and no problems were found. They did tell me if I felt the vehicle was unsafe not to drive it. They indicated they would not provide documentation on the decision. Owners manual doesn't indicate vehicle can roll backwards as "Hill Assist" disengages. Safety Issue