2020 Volkswagen Jetta UNKNOWN OR OTHER

While driving southbound on I-15 near Exit 300 (5300 S, Murray, Utah), the sunroof on my 2020 Volkswagen Jetta SEL suddenly and spontaneously exploded outward without any impact or external object striking the glass. The vehicle had approximately 72,000 miles at the time. There was no tint, film, or modification to the sunroof. The weather was clear, and the road was smooth. The explosion produced a loud gunshot-like sound, followed by glass fragments scattering across the sunshade. Fortunately, the sunshade was closed, which prevented most of the glass from falling into the cabin. However, the incident caused a significant distraction which posed a serious safety risk while driving at highway speeds. No warning lights, messages, or symptoms appeared before the failure. The glass appears to have shattered from internal stress rather than impact, as there were no visible signs of an object strike. The vehicle has not yet been inspected by Volkswagen, law enforcement, or insurance, but the glass remains available for inspection if needed.

While driving down a the road, my husband, 2 children and I, with no cars around us, we heard a loud pop (almost exploding like). We all looked around and then my husband looked up and our sunroof glass was shattered. As we exited the vehicle to take a better look, you could clearly see that the glass was broken from the inside, as if it was popped like a balloon. While no glass fell in the vehicle due to the shade being shut, there was glass all over the top that my husband had to clean up. Unfortunately due to no negligence on our part, we had to file an insurance claim.

Mid-drive, the vehicle gave me a "check starter system" warning, a known 2020 VW Jetta issue. However, my car has not gotten a recall message yet. The message also disappeared again after I turned off the car for 10 minutes and started it again.

Vehicle's sunroof spontaneously shattered while driving, raining down thousands of shards of glass. There was a loud bang, it sounded like a firecracker went off. I was not behind another vehicle and was going 55-60 mph. Another issue that this brought up was that after I had pulled off and assessed what happened, I wasn't initially able to buckle my seat belt due to glass in the receptacle.

After buying this vehicle in June 2020, and the "Emergency SOS Module" never malfunctioning once, I enrolled in VW's free "Safe and Secure" service through the myVW mobile application on March 7, 2024, and immediately received an "Emergency SOS Error" light. The vehicle manual states that the vehicle is not safe to drive and must be taken to the dealership immediately. I then called my local VW dealership asking if I could stop by since I was in the area, and the service department stated that have seen a lot of vehicles coming in with this issue lately and the car must be brought in to replace the emergency call module. Upon bringing my vehicle in, the dealership stated that there is a diagnostic charge of over $250, in addition to the cost of potentially replacing the module (which I'm reading online others have paid between $900-$1,500 for replacement. This is completely unacceptable to pass on a charge to a customer for something that is not included in the vehicle's scheduled (or unscheduled) maintenance list, as well as has nothing to do with the mechanical operation of the vehicle – in addition to posing a safety risk. I never had an issue with this module until the minute I decided to enroll in VW's free "Safe and Secure" service, at which point it seems either they have installed faulty equipment in their vehicles or have an error in their software.

The sunroof shattered after closing the car door from the pressure or motion of the car door closing. The sunroof glass panel popped up in the center and all the shattered glass was in an upward motion indicating the cause was from the pressure in the cabin. There were no visible chips or debris on the sunroof prior to this occurring. I took the vehicle to the Volkswagen dealership for an inspection and repair but they denied warranty coverage even though the vehicle is under the original warranty. Volkswagen claims that a chip or rock would cause the sunroof to shatter from the door closing. This is not a safe or acceptable design - sunroofs should not shatter when car doors are opened/closed or from the movement of the vehicle driving.

IN HEAVY RAIN OR ADVERSE WEATHER THE SONAR IN THE FRONT OF THE CAR FOR CRASH AVOIDANCE FAILS AND STATES THAT IT'S UNABLE TO PROTECT ME AND MY PASSENGERS! THE DEALER HAS HAD THIS CAR FOR 3 TIMES AND THE OWNERS MANUAL DOESN'T TELL THAT IN THOSE SITUATIONS THAT THIS CAN OR SHOULD OCCUR