2006 Chevrolet Malibu Steering

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING), BUT THE REMEDY DID NOT CORRECT THE FAILURE. UPON MAKING A LEFT OR RIGHT TURN, THE STEERING WHEEL DID NOT TURN AND THE CONTACT HAD TO APPLY FORCE TO TURN THE STEERING WHEEL. THE DEALER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 250,000.

MY CAR MAKES CREAKING NOISES WHEN TURNING RIGHT. I HAD TWO OPINIONS AND BOTH SAID INTERMEDIATE DRIVE SHAFT. I HAD IT FIXED BUT IF ITS A RECALL CAN I GET REIMBURST TO PAY DOWN MY CREDIT CARD?

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING THE VEHICLE AND MAKING A RIGHT TURN, THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE POWER STEERING ASSIST NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT, IMMEDIATELY AFTER RETRIEVING THE VEHICLE, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO INDICATED THAT THE POWER STEERING MOTOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT VARIOUS SPEEDS MAKING EITHER A LEFT OR RIGHT TURN, A CLICKING NOISE EMITTED FROM THE STEERING WHEEL AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE FAILURE RECURRED ON SEVERAL OCCASIONS AND APPEARED TO OCCUR IN WET WEATHER. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING). THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE STEERING SHAFT WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,521.

VEHICLE STEERING DOES NOT FULLY RESPOND WHEN ENTERING TURNS, CURVES IN THE ROAD AT TIMES. THIS IS A INTERMITTENT PROBLEM, BUT MORE TIMES THAN NOT. CHEVROLET DEALER DIAGNOSIS IS FAULTY POWER ASSIST MOTOR, MODULE STEERING GEAR AND INTERMEDIATE SHAFT. MY INQUIRES ON WHY THESE MAJOR COMPONENTS HAD FAILED HAVE GONE UNANSWERED. ANY HELP IN THIS MATTER IS GREATLY APPRECIATED. DO HAVE ALL DOCUMENTATION. SIGN, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

WHEN MY WIFE TURNED RIGHT THE STEERING WHEEL LOCKED UP AND LIGHTS ON DASHBOARD STARTED FLASHING IT SCARED MY WIFE

VEHICLE TAKEN TO BLOOMSBURG PA. CHEVY DEALERSHIP FOR BULLETIN 14116. EPS MOTOR CONTROLLER WAS NOT REPLACED AS PER RECALL STATES TO REPLACE. REPEATED CALLS AND VISITS TO DEALERSHIP HAS YIELDED NO RESULTS. THERE INVOICE AFTER SAID REPAIRS WHERE MADE, CLEARLY SHOWS THAT JUST SENSOR ASSEMBLY WAS REPLACED.

WE HAVE RECEIVED A RECALL APPROVAL FOR A DEFECT IN THE TRANSMISSION. BUT THE PROBLEM WE ARE HAVING AND REPORTED TO OUR CHEVY DEALER HAS TO DO WITH THE POWER STEERING NOT WORKING FOR PERIODS OF TIME WHEN WE START THE CAR AS WELL AS DRIVING IT. ITS BEEN THAT WAY FOR AWHILE NOW AS THE DEALER SAID IT WASN'T UNDER RECALL. I BELIEVE IT IS. I NO LONGER DRIVE THE CAR BECAUSE ITS TOO HARD GETTING OUT OF A PARKING SPOT. MY HUSBAND "DEALS" WITH IT. LAST TIME I DROVE THE CAR THE STEERING KICKED IN AGAIN GOING AROUND A TURN AND I ALMOST CROSSED THE LANE. ALSO, AT THAT TIME MY GRANDDAUGHTER HAD TO HELP ME TURN THE WHEEL TO GET OUT OF A PARKING LOT. TRYING TO DO SO ACTUALLY STRAINS MUSCLES IN MY SHOULDER. SHOULDN'T THIS PROBLEM BE UNDER A RECALL? AND IF NOT, WHY NOT? WE WOULD LIKE TO CONTINUE PURCHASING CHEVYS AND WE'RE HOPING FOR CUSTOMER SATISFACTION PERTAINING TO THIS MATTER. THANK YOU VERY MUCH. *TR

WHILE DRIVING, WHEN YOU ACCELERATE, THE STEERING WHEEL LOCKS UP AND YOU CAN'T STEER THE CAR, LOSING ALL CONTROL. IT LOCKS UP FOR A SECOND OR TWO. THIS CAR WAS RECALLED FOR THE STEERING AND MANY OTHER ISSUES, AND WE TOOK IT IN TO BUNNIN CHEVROLET IN CULVER CITY, CA FOR THE REPAIRS. THEY REPAIRED IT UNDER THE RECALL, BUT IT DID NOT FIX THE PROBLEM. THE STEERING STILL LOCKS UP AND IT WILL DO IT MULTIPLE TIMES IN ONE DRIVING SESSION.

I HAVE WAITED 3 YEARS FOR A RECALL FOR MY STEERING PROBLEM WHICH STARTED 08-2012 WITH 75,000 MILES. ON 03/13/15 I TOOK MY CAR IN FOR RECALL #14116 WITH 95,000 MILES. THE FIX FAILED COMPLETELY. ON 07/07/15 WITH 98,800 MILES I RETURNED TO THE CHEV DEALER FOR A DIAGNOSTIC. WHICH COST ME $108.00. RECEIVED A CALL FROM DEALER, AFTER ROAD TEST AND DIAGNOSTIC, COULD NOT FIND A PROBLEM. NEXT DAY I TOOK THE MECHANIC FOR A TEST DRIVE AND HE SAW THE PROBLEM. ALERT CHIMES, POWER STEERING DISPLAYED ON THE DIC AND LOSS OF POWER STEERING. AFTER TALKING WITH CHEVROLET TECH SUPPORT THERE BEST GUESS WAS A FAILING POWER STEERING CONTROL MODULE. AND WANTED $650.00 PLUS THE $108.00 I PAID FOR THE DIAGNOSTIC WITH NO GUARANTEE THAT IT WOULD FIX THE PROBLEM, MAY NEED OTHER REPAIRS. I DECLINED. I DID MORE REACH AND FOUND TECHNICAL SERVICE BULLETIN # 10183A, SPECIAL COVERAGE PROGRAM. 10 YEAR OR 150,000 MILE WARRANTY ON THE STEERING COLUMN ASSEMBLY. RETURNED TO DEALER ON 07/13/15, 98,800 MILES AND HAD STEERING COLUMN ASSEMBLY REPLACED UNDER THE WARRANTY. NO CHANGE, THE PROBLEM STILL EXIST. MORE REACH FOUND ALL VEHICLES THAT HAVE RECALL #14116 DONE FAILED TO WORK. 99% WERE TOLD BY THE CHEV. DEALERSHIP LIKE ME THAT THE POWER STEERING CONTROL MODULE FAILING. I'AM REQUESTING THAT NHTSA ADD THE PART TO THE RECALL LIST OR MAKE CHEVROLET DO SOMETHING TO FIX THE PROBLEM IN LESS THAN ANOTHER 10 YEARS. HAVE CONTACTED CHEVROLET CUSTOMER ASSISTANCE CENTER NO REPLY AFTER 3 BUSINESS DAYS.

GENERAL MOTORS HAS A RECALL FOR DEFECTIVE POWER STEERING THAT CAUSES THE POWER STEERING TO FAIL FOR SEVERAL SECONDS. WE TOOK OUR VEHICLE TO JET CHEVROLET IN FEDERAL WAY, WA TO REPAIR THE VEHICLE ACCORDING TO THE RECALL. THEY CLAIM THEY DID THE WORK. HOWEVER, WITHIN A COUPLE OF DAYS, WE CONTINUED TO HAVE THE EXACT SAME FAILURE WITH THE POWER STEERING. WE CALLED JET CHEVROLET AGAIN TO REPORT IT AND BROUGHT THE VEHICLE IN AGAIN AND THEY SAID IT WAS SOMETHING ELSE CAUSING THE PROBLEM OTHER THAN THE RECALL. THEY WANT TO CHARGE US $100 TO FIND OUT WHAT THE PROBLEM IS. HOWEVER, THE CAR IS DOING EXACTLY THE SAME THING AS BEFORE WE BROUGHT IT IN FOR THE RECALL. IF THEY DID REPLACE THE PART, I'M SURE IT MUST HAVE BEEN A DEFECTIVE PART. WE NEED SOMETHING DONE TO REMEDY THIS SITUATION TO AVOID A POTENTIAL CAR ACCIDENT.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. WHILE DRIVING BETWEEN 40-70 MPH, THE STEERING WHEEL SEIZED AND EXCESSIVE FORCE WAS REQUIRED WITHOUT WARNING. AFTER A COUPLE OF MINUTES, THE STEERING WHEEL PERFORMED NORMALLY. THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE DEALER WAS TO REPLACE THE TORQUE SENSOR. THE VEHICLE WAS REPAIRED UNDER THE RECALL; HOWEVER, THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT THEY WERE UNABLE TO LOCATE A FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT 55 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE FAILURE RECURRED ONCE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 101,000. UPDATED 09/10/15*LJ UPDATED 11/28/2017*CN

WHILE DRIVING ON THE FREEWAY, THE STEERING WHEEL LOCKED FOR A MOMENT; THEN, IT WENT BACK TO NORMAL. WHEN THIS HAPPENED, THE SIGNAL LIGHT SOUNDED, BUT THE SIGNAL LIGHT WERE NOT ON. THIS HAS HAPPENED TO MY HUSBAND AND I, COUPLE OF TIMES' I AM SCARED TO DRIVE MY CAR. I CALLED CHEVROLET (DEALER) THEY DID NOT KNOW WHAT IT IS. I CALLED A FRIEND OF MINE; HE'S A MECHANIC AND TOLD ME THAT HE DID NOT KNOW EITHER. THANK YOU *TR

EVER SINCE I PURCHASED MY MALIBU WITH AROUND 400 MILES, I HAVE HAD A CONTINUOUS KNOCK, WHICH I CAN HEAR AT LOWER SPEEDS TURNING THE WHEEL IN EITHER DIRECTION WHETHER THAT BE IN DRIVE OR REVERSE. TO ME IT SOUNDS LIKE IT IS COMING FROM MY STEERING COLUMN. FROM WHAT I REMEMBER, I BELIEVE I WAS TOLD IT WAS SOME TYPE OF JOINT WHICH KNOCKS FROM FRICTION AND THAT IT WOULD JUST NEED LUBRICATION IN TIME. OVER THE YEARS THE KNOCKING HAS CONTINUED AND SEEMS TO BE GETTING A LITTLE LOUDER, WITH MINOR SHAKING OF THE STEERING COLUMN WHEN DRIVING ON THE FREEWAY OR ACCELERATING TO HIGHER SPEEDS. I AM NOT SURE IF THIS MIGHT BE A POSSIBLE RECALL FOR THIS VEHICLE, BUT I DID SEE A STEERING RECALL FOR THIS YEAR, MAKE AND MODEL. IS THIS A RECALLED ITEM I HAVE NOT RECEIVED WORD OF? I HAVE HAD THREE RECALLS BROUGHT TO MY ATTENTION IN THE PAST SIX MONTHS WHICH I HAVE HAD TAKEN CARE OF, I WAS GIVEN NO FURTHER WORD OF THERE BEING ANY FURTHER ISSUES. THIS PROBLEM HAS BEEN WITH THIS VEHICLE FROM THE BEGINNING SO I AM NOW CURIOUS TO KNOW IF THESE PARTS HAVE BEEN RECALLED. *TR

POWER STEERING ALL OF A SUDDEN STOPPED WORKING ON MULTIPLE OCCASIONS.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 25 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND THE POWER STEERING WARNING LIGHT ILLUMINATED. IN ADDITION, WHILE MAKING A LEFT OR RIGHT TURN, THERE WAS AN ABNORMAL SOUND COMING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING ASSIST MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 5 MPH, THE POWER STEERING FAILED. THE CONTACT HAD THE FAULTY POWER STEERING MODULE ASSEMBLY REPLACED. THE VEHICLE WAS REPAIRED ON MARCH 20, 2014. THE VIN AND FAILURE MILEAGE WERE UNAVAILABLE. .... UPDATED 08/30/15 *BF UPDATED 12/10/15 *JS

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 25 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS RESTARTED AND RESUMED NORMAL OPERATION. THE FAILURE RECURRED NUMEROUS TIMES. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 151,789.

LOST POWER STEERING AS I WAS MAKING A LEFT TURN. THE CAR WOULD NOT TURN AND THE BRAKE WAS NOT SLOWING DOWN THE CAR. ENDED UP GOING UP THE SIDEWALK AND CRASHING INTO A WALL CAUSING THE AIRBAGS TO DEPLOY AND SPRAINING MY WRIST DOWN TO MY ELBOW ALONG WITH MINOR BACK PAINS. NOW THE CAR IS CONSIDERED A TOTAL LOSS. *TR

DRIVING DOWN THE ROAD MY POWER STEERING LIGHT CAME ON AND NOW MY WHEEL KICKS ALL OVER WHEN I TRY TO DRIVE! I TOOK IT TO A GM DEALER AND THEY SAID THAT IT'S THE POWER STEERING MOTOR AND THAT IT HAS A DEAD SPOT THEY SAID THEY HAVE HAD A LOT OF THIS GOING ON IN MY MAKE AND MODEL! THIS SHOULD BE A RECALL! ALSO MY CAR IS STARTING TO DECIDE WHEN IS SHOULD START. SOMETIMES IT TAKES A FEW TRIES AND I HAVE TO PRAY IT STARTS AND AFTER THAT IN PARK IT WILL IDLE HIGH THE CAR ISN'T THAT OLD AND DOESN'T HAVE HIGH MILEAGE IT SHOULDN'T BE DOING THIS! *TR

AS I WAS MAKING A TURN ON A MAJOR STREET MY POWER STEERING WENT OUT; I HAVE CONTACTED GM NUMEROUS TIMES TO THIS FIXED, WITHOUT ME HAVE TO COME OUT OF MY POCKET OVER $1,000.00 TO GET THIS FIXED. IN 2014 THERE WAS A RECALL DONE AND WHEN I WENT TO THE DEALERSHIP TO GET THIS FIXED THEY ARE STATING THAT IT IS THE POWER ASSIST (MOTOR) THAT IS OUT AND NOT PART OF THE RECALL. I HAVE BEEN BACK IN CONTACT WITH GM BUT NOTHING HAS BEEN DONE TO RESOLVE THIS. IT IS VERY DIFFICULT TO DRIVE THE CAR WITHOUT ANY POWER STEERING AND THIS IS A HAZARD TO OTHER DRIVERS AS WELL AS ME. GM SHOULD NOT BE ALLOWED TO CONTINUE MANUFACTURING AND SELLING FAULTY VEHICLES. THIS IS MY LAST TIME REACHING OUT TO TRY TO GET A RESOLUTION, IF NOTHING CAN BE DONE TO FIX MY CAR. I WILL HAVE TO PURSUE LEGAL AND CONSTITUTIONAL RIGHTS AS A CONSUMER AGAINST GM. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE LOST POWER AND THE STEERING WHEEL BECAME TIGHT. THE CONTACT HAD TO APPLY FORCE TO TURN THE STEERING WHEEL. THE CONTACT HAD TO TURN THE VEHICLE OFF AND RESTARTED IT IN ORDER TO RESET THE COMPUTER. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING), BUT THE FAILURE RECURRED WEEKS LATER. THE VEHICLE WAS TAKEN BACK TO THE AUTHORIZED DEALER WHO DIAGNOSED THAT THE POWER STEERING CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

LOSS OF STEERING CONTROL WHILE DRIVING ON EXPRESSWAY AT 50+MPH. DIFFICULT TO MAINTAIN CONTROL. ABLE TO SLOW DOWN AND EXIT FREEWAY. DEALER WAS CLOSE BY SO LEFT ON LOT OVERNIGHT. CHECK ENGINE LIGHT ALSO HAD COME ON. DEALER REPORTED FOUND CODE C0550 WHEN RUNNING DIAGNOSTICS. DEALER INFORMED THE P/S CONTROL MODULE NEEDED REPLACED. INFORMED WAS NOT COVERED UNDER A CURRENT RECALL. DEALER HAD VEHICLE FOR OVER 1 WEEK BECAUSE FIRST UNIT DID NOT FIX THE PROBLEM. SEARCH REVEALS SAME ISSUE AS IN BULLETIN 14118 FOR MODEL YEAR 2008 MALIBU.