2006 Ford Escape SERVICE BRAKES, HYDRAULIC

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE BRAKE PEDAL WAS DEPRESSED BUT WAS FIRM. THE SERVICE BRAKE SYSTEM WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO RON DUPRATT FORD LOCATED AT 1320 NORTH FIRST ST, DIXON, CA 95620, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE HYDRAULIC CONTROL UNIT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000.

2006 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO BRAKE FAILURE. *SMD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *SMD THE CONSUMER STATED THE SERVICE BRAKE SYSTEM WAS A SPORADIC ISSUE FOR A VERY LONG TIME. WHEN THE ERROR MESSAGE DISPLAYED, THERE WAS NO PRESSURE ON THE BRAKE PEDAL, THE POWER BRAKES FAILED, AND IN ORDER TO GET THE BRAKES TO WORK AT ALL, HE HAD TO PRESS THE PEDAL TO THE FLOOR. THE CONSUMER EXPERERIENCED A LOSS OF POWER, THE INSIDE LIGHTS DIMMED AND THE RADIO CUT OUT. IT WAS DETERMINED THE BATTERY NEEDED TO BE REPLACED. FOUR MONTHS LATER, THE SPORADIC BRAKE SYSTEM MESSAGE ILLUMINATED. THE DEALER WAS UNABLE TO FIND A PROBLEM. UPDATED 08/24/15*JB

BRAKE FAILURE. IN ONE SHORT DISTANCE, BOTH FRONT FLEXIBLE HOSES CARRYING BRAKE FLUID RUPTURED TOTALLY LOSING BRAKE RESPONSE. CAR WAS BROUGHT UNDER CONTROL BY OTHER MEANS. WE COULD HAVE BEEN KILLED IN A VARIED CIRCUMSTANCE. IT WAS NECESSARY TO HAVE THE CAR TOWED FOR REPAIRS.

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES. THE TECHNICIAN INFORMED THE CONTACT THAT THE ELECTRONIC HYDRAULIC BRAKE SYSTEM WOULD NEED TO BE REPLACED. THE VEHICLE WAS SCHEDULED FOR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. UPDATED 11/19/13*LJ

ABS LIGHT AND BRAKE LIGHT CAME ON WHEN I GOT INTO THE CAR TO GO TO WORK AFTER DRIVING IT THE PREVIOUS DAY WITH NO PROBLEMS. BRAKE PEDAL BECAME SOFT AND BRAKING WAS NOT SMOOTH AND WHEN BRAKE PEDAL WAS PRESSED IT MADE A SQUEALING NOISE. DEALER DIAGNOSED IT AS A FAULTY ABS MODULE REPLACEMENT COST OF $3000. *TR

*THIS IS THE SECOND TIME THAT I HAVE HAD A COMPLETE "BRAKE FAILURE" WHILE DRIVING MY 2006 FORD ESCAPE HYBRID IN TRAFFIC. THIS LAST TIME, I WAS DRIVING ON A FREEWAY IN BEDFORD, TEXAS AND OBSERVED THAT TRAFFIC IN THE DISTANCE WAS STOPPING FOR CONSTRUCTION. I APPLIED MY BRAKES BUT THE PEDDLE WENT TO THE FLOOR. I HAD TO EXIT THE ROADWAY ONTO THE SHOULDER TO AVOID OTHER VEHICLES. I PUT MY VEHICLE IN LOW GEAR FROM DRIVE AND APPLIED MY EMERENGY BRAKE TO STOP MY CAR. THIS IS THE "SECOND" TIME I HAVE HAD TO TAKE EVASIVE ACTION TO AVOID A COLLISION WITH THIS BAKE PROBLEM. THE "ABS" LIGHT CAME ON, THE RED BRAKE LIGHT CAME ON, AND THERE WAS A COMPUTER MESSAGE ON THE DASH THAT READ "SERVICE BRAKE SYSTEM". THE FIRST TIME THAT I EXPERIENCED THIS SAME PROBLEM, I TOOK MY CAR INTO THE DEALERSHIP IN FOR WARRANTY REPAIR. THEY ADVISED THAT SINCE THE "CODE LIGHTS" WERE NOT ON AT THIS VERY MOMENT, THEY WERE NOT ABLE TO DIAGNOSIS THE PROBLEM. I WAS INSTRUCTED TO DRIVE THE ESCAPE UNTIL THE "CODE LIGHTS" CAME BACK ON AND THEN BRING IT BACK FOR SERVICE!!! I COMPLIED TO THIS REQUEST AND BOUGHT THE TRUCK BACK IN WITH THE "CODE LIGHTS" ON AND THE MESSAGE READING. DEALERSHIP WORKED ON THE VEHICLE FOR SEVERAL DAYS AND THE ASSIST SERVICE MANAGER DROVE IT FOR A COUPLE OF DAYS TO CHECK IT OUT. THE TRUCK WAS RETURNED TO ME WITH ASSURANCE THAT THE "BRAKE PROBLEM" WAS FIXED. ON JULY 9, 2011, I AGAIN HAD A "COMPLETE BRAKE FAILURE" WITH MY TRUCK(SEE ABOVE) ON JULY 11, 2011, I TOOK MY ESCAPE HYBRID BACK TO THE DEALERSHIP AND ADVISED THE ASSISTANT SERVICE MANAGER, ABOUT THE PROBLEM AND WHAT ALMOST HAPPENED TO ME IN TRAFFIC. I ALSO SHOWED HIM SOME OF THE OTHER COMPLAINTS ABOUT THIS SAME TYPE OF "BRAKE FAILURE" THAT HAS OCCURRED ON OTHER FORD ESCAPE HYBRIDS. I HAVE ALSO CALLED FORD CORPORATE TO START A COMPLAINT! "DOES IT TAKE SOMEONE GETTING KILLED OR INJURIED BEFORE SOMETHING IS DONE?" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT *CN

2006 FORD ESCAPE XLT, C/O LEFT FRONT ABS (ANTI LOCK BRAKING SYSTEM) TONE RING FAILURE... AT 94,782 MILES ON MY ODO MY LEFT FRONT ABS TONE RING BROKE COMPLETELY IN-HALF CAUSING A ABS SENSOR FAILURE AND THE BRAKES BECAME TEMPORARILY SEMI-UNRESPONSIVE FOR A FEW SECONDS ( 3-5 SECONDS ) WHEN I PRESSED ON THE BRAKES TO STOP THE CAR. BRAKING WAS GREATLY REDUCED AS IF THE CAR THOUGHT I WAS SLIDING ON ICE OR SNOW. AFTER THE SYSTEM DETECTED FAILURE ( 3-5 SECONDS) THE ABS LIGHT CAME ON IN MY DASHBOARD AND THE ABS SYSTEM SEEMED TO BE DEACTIVATED BY THE CAR. WHEN I GOT HOME AND TOOK THE LEFT FRONT WHEEL OFF AND INSPECTED MY BRAKES AND ABS SENSOR, I NOTICED THE LEFT FRONT ABS TONE RING WAS COMPLETELY RUSTED, FREE SPINNING LOOSELY AROUND THE AXLE AND WAS BROKEN COMPLETELY ON ONE END. I WENT ONTO GOOGLE AND RESEARCHED THIS PROBLEM AND FOUND THAT MANY OTHER PEOPLE HAVE ENCOUNTERED THE SAME PROBLEMS ON THEIR FORD ESCAPES. I WOULD LIKE THIS TO BE INVESTIGATED AS I THINK THAT PERHAPS THE ABS TONE RINGS FORD USED ARE FAULTY AND COULD POSE A DANGER TO MOTORIST BY CAUSING SIGNIFICANT LOSS OF BRAKING ABILITY OVER A FEW SECONDS AS DIRECT RESULT OF THE ABS TONE RING FAILURE. THE ABS TONE RING IS REPLACEABLE BY FORD OR YOU CAN BUY THE PART AT A PARTS STORE. REPAIR DOES INVOLVE REMOVING PART OF THE AXLE, SO IT IS BEST DONE BY A MECHANIC OR TRAINED PROFESSIONAL. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT WAS TRAVELING 50 MPH WHEN THE ABS WARNING LIGHT ILLUMINATED. THE CONTACT APPLIED THE BRAKES AND THERE WAS A REDUCTION OF 80% BRAKING POWER. THE CONTACT REFERENCED TECHNICAL SERVICE BULLETIN 10024326 (SERVICE BRAKE: CONTROL UNIT MODULE) AND BELIEVED THE FAILURE TO BE THE SAME. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 81,000. UPDATED 4/4/11 *CN THE REPAIR SHOP INSTALLED A MASTER CYLINDER. UPDATED 05/23/11

BRAKE LIGHT COMES ON, SERVICE BRAKE SYSTEM MESSAGE ON DASH DISPLAYS, AND ABS LIGHT DISPLAYS. VEHICLES BRAKES FAIL AND EVEN WHEN APPLYING BRAKE PEDAL COMPLETELY VEHICLE DOES NOT STOP COMPLETELY WITHOUT PUMPING BRAKES SEVERAL TIMES OR USING EMERGENCY BRAKE. THIS HAPPENED A COUPLE TIMES LAST WEEK (WITHOUT WARNING LIGHTS) AND TOOK IT TO A LOCAL MECHANIC WHO INSPECTED BRAKES AND ADVISED EVERYTHING LOOKS FINE. OCCURRED AGAIN THIS EVENING WITH WARNING LIGHTS. TURNED OFF VEHICLE & RESTARTED AND NO LIGHTS AND NO PROBLEM BRAKING. RESEARCHED ONLINE AND THERE ARE NUMEROUS COMPLAINTS OF THIS IN BLOGS, COMMENTS, ETC. *TT

TL*THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE BRAKE PEDAL BEGAN TO PULSATE EXCESSIVELY WHEN PRESSURE WAS APPLIED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE ABS SENDING UNIT WAS REPLACED; HOWEVER THE FAILURE CONTINUED TO OCCUR AFTER THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 46,200. UPDATED 07/08/11 *BF UPDATED 3/16/12 *CN

BRAKE FAILURE RESULTING IN THE BRAKE PEDAL GOING TO THE FLOOR AND A LOSS OF HYDRAULIC OR POWER BRAKING. VEHICLE DOES STOP AFTER A HARD PRESSING OF BRAKE PEDAL. THIS IS SOMETIMES FOLLOWED BY A YELLOW ABS LIGHT AND RED BRAKE LIGHT WARNING. THE PROBLEM IS FIXED BY TURNING THE CAR OFF AND BACK ON. I AM NOT KIDDING. ITS LIKE REBOOTING THE COMPUTER. THIS STARTED ABOUT 2 YEARS AGO. I REPORTED IT TO FORD WHO SAID THEY DO NOT KNOW ANYTHING ABOUT IT AT THE DEALER AND NATIONAL LEVEL. I TOOK THE CAR IN FOR AN OIL CHANGE AT THE DEALERSHIP AND MENTIONED THE INTERMITTENT BRAKE FAILURE. AFTER THE OIL SERVICE, THE PROBLEM WENT AWAY FOR A YEAR. I THOUGHT FORD HAD SECRETLY FIXED IT WHILE THEY WERE CHANGING THE OIL. THEN ABOUT A WEEK AGO THE PROBLEM HAS RETURNED AND HAS HAPPENED 10 TIMES. I THINK IT IS RELATED TO THE CAR NOT HAVING ENOUGH POWER BECAUSE THIS HAPPENS WHILE THE ICE (INTERNAL COMBUSTION ENGINE) IS OFF. PERHAPS IT IS RELATED TO RUNNING THE AIR CONDITIONING SINCE IT STOPPED AFTER THE SUMMER AND RETURNED AGAIN. THE ICE TURNS OFF WHILE BRAKING AT SPEEDS BELOW 40MPH SO THAT IS PROBABLY RELATED. *TR

THE BRAKES FAIL ON A REGULAR BASIS WHILE SLOWING DOWN FROM SPEEDS BETWEEN 10 AND 35 MPH. IT OCCURS AS A SUDDEN RELEASE OF BRAKING PRESSURE WHILE STEPPING ON THE BRAKE PEDAL TO SLOW DOWN. AT THAT TIME A MOMENTARY WARNING LIGHT COMES ON FOR SEVERAL SECONDS AND THE SYSTEM APPEARS TO GO INTO A FAIL-SAFE MODE THAT ALLOWS MANUAL OPERATION OF THE BRAKES. THIS CAUSES A LARGE INCREASE IN BRAKING DISTANCE AND I CONSIDER IT VERY DANGEROUS. THIS FAILURE SEEMS TO BE RELATED TO THE HYBRID BRAKING SYSTEM AND MAY BE COMMON TO OTHER HYBRID VEHICLES. AFTER STOPPING THE WARNING LIGHT GOES AWAY AND THE BRAKES WILL AGAIN FUNCTION NORMALLY. THE FAILURE DOES NOT OCCUR CONTINUOUSLY BUT IT DOES OCCUR ALMOST EVERY DAY THAT IT IS DRIVEN. THE CAR HAS BEEN IN A REPAIR SHOP NUMEROUS TIMES WITH MANY PART REPLACED BUT THE PROBLEM CONTINUES TO EVADE OUR FLEET MECHANICS. THIS IS AN INHERENT PROBLEM WITH THIS VEHICLE AND COMMONLY KNOWN WHERE THERE ARE LARGE FLEETS OF HYBRID VEHICLES. MY CO-WORKER DRIVES THE SAME TYPE OF ESCAPE HYBRID AND HE HAS THE SAME FAILURE. PLEASE INVESTIGATE WITH FORD AND/OR TOYOTA. A SIMILAR PROBLEM HAS BEEN SEEN WITH TOYOTA PRIUS IN OUT FLEET. *TR CONSUMER STATED AT SOME PERIOD AROUND 2014-15 THE CAR WAS SENT TO THE FLEET DEPT AGAIN FOR BRAKING PROBLEMS AND THERE WAS SOME BREAKTHROUGH WITH REPAIRS. VEHICLE WAS TRANSFERRED TO DIFFERENT NYCDEP DRIVER FOR A COUPLE OF YEARS. VIN NUMBER NOT AVAILABLE BUT COULD INQUIRE WITH CONSUMER'S TRANSPORTATION SECTION. UPDATED 6/11/18*JB

I JUST BOUGHT A 2006 FORD ESCAPE HYBRID. THE SERVICE BREAK SYSTEM LIGHT AND MESSAGE CAME ON MONDAY, THE 2ND TIME I DROVE IT, ON THE WAY TO WORK. I STOPPED AT A GAS STATION BUT IT TURNED OFF. NEXT MORNING, SAME THING SO I CHECKED FLUIDS. IT WAS OFF AGAIN THE REST OF THAT DAY. LIT UP AGAIN WEDNESDAY. I MADE IT THAT EVENING TO A SERVICE STATION BEFORE THEY CLOSED (VERY RURAL AREA). THE WARNINGS WERE NOT ON AND HE COULD NOT SEE ANYTHING OBVIOUS ON PRELIMINARY INSPECTION BUT SAID TO BRING IN IN THE MORNING IF THE WARNING WAS BACK. THURSDAY IT ACTED FUNNY ON MY DRIVEWAY. THE NEXT CURVE I FOUND OUT WHY, NO BREAKING POWER EVEN WITH THE EXTREMELY STIFF AND DIFFICULT PEDAL TO THE FLOOR. I FINALLY GOT IT TO A STOP WAY PAST THE CRAZY RIDE AROUND THE CURVE. I STOPPED TO CALM MYSELF AND DECIDE IF IT WAS POSSIBLE TO GET TO TOWN. I DECIDED THE E-BRAKE SEEMED TO STOP IT IF I KEPT IT VERY SLOW. SO I PROCEEDED TO TOWN-NOT TO A FORD DEALER BECAUSE OF SOME VERY SCARY BIG HILLS, BUT INSTEAD TO THE SERVICE STATION WHO I TRUST. HE WAS BOOKED A WEEK AND A HALF AND HE DIDN'T KNOW IF HIS COMPUTER HAD THE HYBRID PROGRAMMING TO CHECK IT. SO I HAD TO TOW IT 63M TO THE DEALER I GOT IT FROM, THINKING THEY WOULD STAND BY IT OR IT WOULD BE COVERED BY THE "DRIVETRAIN PLUS" SERVICE AGREEMENT I PURCHASED TO COVER ANY SCARY PRICED REPAIRS THAT CROP UP ON OLDER CARS. IT WAS SOLD AS-IS, AND IOWA HAS NO LEMON LAW APPARENTLY, THE PLAN I PURCHASED SOUNDS LIKE IT WON'T COVER IT, AND THEY OFFERED ME A MEASLY 10% OFF THE BILL THAT IS ABOUT HALF AGAIN WHAT I PAID FOR THE CAR. I GOT TO DRIVE MY NEW USED CAR 4 1/2 TIMES. ALL I CAN DO IS THANK MY LUCKY STARS MY KIDS WEREN'T IN THE CAR, THERE WASN'T A CAR NEAR ME, I WASN'T COMING DOWN ONE OF THE STEEP AND CURVY RIVER BLUFFS ON MY WAY TO OR FROM WORK, OR ANY NUMBER OF OTHER SCARY SCENARIOS THAT COULD HAVE BEEN. FALIURE OF THE BRAKE SYSTEM'S HYDRAULIC CONTROL UNIT HCU AND MASTER CYLINDER IS EXTREMELY DANGEROUS AND A DESIGN FLAW MANY HAVE EXPERIENCED.

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE SYSTEM FAILED WITH THE ILLUMINATION OF THE ABS WARNING LAMP. THE CONTACT ALSO MENTIONED THAT HE WAS ABLE TO STOP THE VEHICLE BY USING THE EMERGENCY BRAKE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 07V156000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 64,000.

I WAS DRIVING HOME FROM WORK, GOING ABOUT 35 MPH WHEN I FELT MY CAR START TO SLID LIKE IT WAS ON ICE EVEN THOUGH THE PAVEMENT WAS DRY. MY ABS LIGHT AND MY SERVICE 4WD LIGHT CAME ON. I HAD A VERY HARD TIME GETTING HOME BECAUSE THE BRAKES WERE FAILING. I CAME HOME GOOGLED IT AND REALIZED THAT IT WAS MY TONE RING AND THAT IT WAS A COMMON PROBLEM. SURE ENOUGH NEXT DAY TOOK IT TO A FORD DEALERSHIP AND THAT'S WHAT IT WAS. THE PROBLEM DATES BACK TO 2000 FORD ESCAPES AND AS RECENT AS 2010 FORD ESCAPES. THE MECHANIC AT THE DEALERSHIP ADVISED ME THAT THE RING COULD SNAP JUST FROM TURNING A CORNER. I DON'T KNOW WHY FORD ISN'T BEING REQUIRED TO FIX THIS ISSUE. WHY ARE THE BEING ALLOWED TO PUT THIS SAME PRODUCT IN THE VEHICLE YEAR AFTER YEAR KNOWING ITS INFERIOR. WHEN THE RING BREAKS IT MAKES IT VERY HARD TO STOP THE CAR WHICH IS A HUGE SAFETY HAZARD.

"ABS" WARNING LIGHT ILLUMINATED AND "SERVICE BRAKE SYSTEM" APPEARED ON DISPLAY. APPLIED BRAKE PEDAL AND ANTI-LOCK ENGAGED CAUSING A "CHATTERING" SOUND FROM BRAKES AND SEVERE VIBRATION. EXTRA PRESSURE ON BRAKE PEDAL NEEDED TO BRING VEHICLE TO A SAFE STOP. *TR

FORD ESCAPE HYBRID 2006 ABS AND BRAKE FAILURE LIGHT COME ON, LOSE POWER BRAKING. MUST PUSH VERY HARD ON BRAKE PETAL TO STOP CAR, HAS HAPPENED APPROX. 8 TIMES. AFTER STOPPING CAR, I CAN USUALLY TURN KEY OFF AND THEN RESTART CAR AND PROBLEM IS GONE. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE ABS WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY THE DEALER WHO INFORMED THE CONTACT THAT THEY WERE UNABLE TO PERFORM A FULL DIAGNOSIS AND WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 59,000.

WE OWN A 2006 FORD ESCAPE HYBRID 4WD. IT HAS APPROX. 56,000 MILES ON IT. THE ABS SYSTEM FAILED ON IT IN DEC. THE FORD DEALERSHIP IN OUR AREA CAME BACK WITH AN ESTIMATE OF $6000 FOR REPAIR SECONDARY TO A FAILURE IN THE HYDRAULIC CONTROL UNIT COMPUTER WHICH CONTROLS THE ABS SYSTEM. THE PART ITSELF IS $4300. WE CONTACTED FORD WHOSE RESPONSE WAS THAT WE SHOULD HAVE BOUGHT THE EXTENDED WARRANTY. THE DEALER THEN CONTACTED FORD DIRECTLY AND FORD AGREED TO TAKE $1000 OFF THE PART COST WHICH BROUGHT OUR REPAIR DOWN TO $5000. OUR NON-FORD MECHANIC WAS ABLE TO PURCHASE A USED PART FOR $350, INSTALL IT THEN TAKE IT TO FORD TO REFLASH THE COMPUTER COMPONENTS. FORD CAME BACK TO US AFTER ABOUT A WEEK AND SAID THEY COULD NOT REFLASH THE SYSTEM BECAUSE THOSE COMPONENTS COULD ONLY BE PROGRAMMED ONCE ON THE INITIAL BUILD. WE WOULD BE FORCED TO PURCHASE A NEW PART FROM FORD WHO THEN ARE ALSO THE ONLY ONES WHO POSSESS THE SOFTWARE TO GET THE VEHICLES WORKING AGAIN. I LOOKED ONLINE AND WOULD BE ABLE TO PURCHASE THE PART FOR $2300 BUT COULD ONLY HAVE A FORD DEALER DO THE REMAINDER OF THE WORK TO GET THE COMPUTER SYSTEM TO WORK. NOT SURE IF ANY FORD DEALERSHIP WOULD ALLOW US TO BRING IN OUR OWN PART WE PURCHASED OFF THE INTERNET IF WE WERE TO PURCHASE THE CHEAPER PART. IN ADDITION, IT TURNS OUT FORD IS REQUIRING PARTS DEALERS TO RETURN THE USED PART TO FORD AFTER PURCHASING THE NEW PART. FORD THEN REMANUFACTURES THE PART (WHICH THEY GOT FOR FREE FROM THE CONSUMER) AND RESELLS IT AS A NEW PART FOR $4300 TO SOME OTHER UNSUSPECTING HYBRID OWNER. SINCE OUR CAR IS UNDRIVEABLE WITHOUT THE REPAIR, IT FEELS LIKE FORD IS GROSSLY TAKING ADVANTAGE OF THE CIRCUMSTANCES IN SITUATIONS SUCH AS THESE TO UNFAIRLY GOUGE THEIR CUSTOMERS. PART # 7M6Z2C286B. *TR

BRAKES ON MY 2006 FORD ESCAPE HYBRID FAILED AT HIGHWAY SPEED AND THE ABS AND BRAKE LIGHT CAME SIMULTANEOUSLY. BY PINNING THE BRAKE TO THE FLOOR I WAS ABLE TO SLOW THE VEHICLE IN THE SHOULDER. TURNING THE CAR OFF AND BACK ON "RESOLVED" THE ISSUE AND I WAS ABLE TO DRIVE HOME. THE PROBLEM HAPPENS RANDOMLY AND WITHOUT WARNING. I HAVE PLACED A CALL TO THE DEALER BUT HAVE NOT HEARD BACK YET. LOOKING ON LINE IT SEEMS TO BE A COMMON PROBLEM, YET NO RECALL HAS BEEN ISSUED FOR THIS VERY DANGEROUS SITUATION. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 50 MPH, THE ABS LIGHT AND FOUR WHEEL DRIVE LIGHT SUDDENLY ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE AND PARKED. UPON RESTARTING THE VEHICLE, THE CONTACT NOTICED THAT NONE OF THE LIGHTS WERE ILLUMINATED; HOWEVER, AFTER DRIVING APPROXIMATELY 4 MILES, THE LIGHTS ILLUMINATED AGAIN. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE CONTINUED TO OCCUR. THE FAILURE MILEAGE WAS 70,683 AND THE CURRENT MILEAGE WAS 70,890.

I OWN A 2006 FORD ESCAPE. IT HAS 70,683 MILES ON IT. I WAS DRIVING ON THE HIGHWAY (50 MPH) AND NOTICED THE ABS LIGHT ON AND THE 4WD LIGHT WAS FLASHING. THIS HAS OCCURRED TWICE IN THE LAST TWO DAYS. THE FIRST OCCURRENCE, I ADDED BRAKE FLUID AND THE LIGHTS WENT OUT. THIS HAPPENED AGAIN TWO DAYS LATER ON THE HIGHWAY AND AROUND THE SAME RATE OF SPEED.. *TR

A COUPLE MONTHS AGO, I TOOK MY ESCAPE HYBRID TO HAVE THE BRAKES CHECKED OUT. NEEDLESS TO SAY, THEY CHECKED IT OUT AND SAID EVERYTHING WAS FINE AND I WAS ON MY WAY A COUPLE OF HOURS LATER. THEN YESTERDAY, MY ABS AND BRAKE LIGHTS ILLUMINATED AND THEN CHECK BRAKE SYSTEM CAME ON. AFTER THIS OCCURRED, MY BRAKES GO OUT AND THEN I MUST COME TO A ROLLING STOP ON THE SIDE OF THE ROAD WHILE TRYING TO AVOID HITTING ANYONE. IT OCCURRED 6 TIMES AT DIFFERENT SPEEDS (20MPH & 70MPH) I THEN RETURNED IT TO THE DEALERSHIP YESTERDAY AND ASKED THEM TO LOOK OVER IT. TODAY, I AM TOLD THAT I NEED A NEW ABS SYSTEM INSTALLED WITH THE HYDRAULIC/ELECTRIC CONTROL UNITS TOTALLY $7,400. OF COURSE, THERE IS NO WARRANTY FOR THIS. I HAVE BEEN RESEARCHING THIS ISSUE ONLINE AND HAVE NOTICED SEVERAL POSTING REGARDING A SIMILAR ISSUE HOWEVER STILL NO RECALL. I WOULD ASSUME A FACTORY DEFECT REGARDING THE BRAKES WOULD BE SIGNIFICANT ENOUGH FOR A RECALL BEFORE SOMEONE GETS KILLED. *TR

I WAS DRIVING APPROXIMATELY 40 MILES PER HOUR, APPROACHING A RED LIGHT AND BUSY INTERSECTION. I APPLIED BRAKES (VIA PEDAL) AS USUAL, BUT HAD NO BRAKING POWER / CORRESPONDING SLOWDOWN. I HAD TO JAM MY FOOT TO THE FLOOR AND COVER THE EMERGENCY BRAKE IN CASE I NEEDED IT, AND THANKFULLY I WAS THE FIRST CAR AT THE LIGHT SO THERE WAS NO ACCIDENT. THE REST OF THE DRIVE, IT TOOK AT LEAST 5 TIMES LONGER/MORE DISTANCE TO SLOW THE VEHICLE TO A STOP THAN NORMAL AND AT THE SAME MOMENT I LOST BRAKING POWER, A CHIME SOUNDED & BOTH THE ABS AND BRAKE(S) LIGHT ON THE DASH LIT UP; MESSAGE CENTER READ "SERVICE BRAKES SOON". I JUST HAD THE VEH IN FOR ITS 40K MILE SERVICE 2 DAYS AGO & IT HAD NOTHING WRONG WITH IT--BRAKES WERE ALL LISTED AS TOP CONDITION. NOW I'M ABSOLUTELY TERRIFIED TO DRIVE THE VEHICLE, UNSURE WHEN THIS CONDITION WILL RECUR (THE LIGHTS RESET & AND I CHECKED TODAY--THE BRAKES ARE WORKING AGAIN, FOR NOW.) WHEN THE CONDITION OCCURS, BRAKING IS AN ODD SLOW PULSING, LIKE A SLOWED DOWN VERSION OF AN EMERGENCY ABS STOP ("PUMPING THE BRAKES" FEELING.) I'VE NEVER HAD BRAKE PROBLEMS UNTIL THIS INCIDENT. WHEN I TURNED THE CAR OFF AND RESTARTED IT, THE ABS & BRAKE LIGHTS CLEARED AND, FOR NOW AT LEAST, THE BRAKES *SEEM* TO BE WORKING BUT I CAN'T CHANCE IT. GETTING IT TOWED FOR SERVICE. *TR

I WAS DRIVING IN TOWN, DOING NOTHING OUT OF THE ORDINARY WHEN THE VEHICLE SUFFERED COMPLETE ABS BRAKE SYSTEM FAILURE. I AM NOW AFRAID TO DRIVE IT. *TR