2020 Ford Expedition POWER TRAIN,ENGINE

This suv has 10 speed transmission that has faulty harsh shifting hesitation, acceleration problem when shifting on highway or in situations when you need to slow down and or accelerate. This has happened many times while trying to get on the highway and switching lanes. I have almost been run over because it stalled someone is going to get killed. I have had the Powertrain control module pcm reprogramed twice and it keeps happening. Ford is aware of this. They need to get this trucks off of the road!

The contact owns a 2020 Ford Expedition. The contact stated while driving approximately 60 MPH, the check engine warning light illuminated, and the vehicle lost motive power. The vehicle was taken to a local dealer who diagnosed the vehicle and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle lost motive power with the check engine warning light illuminated. The contact returned the vehicle to the same dealer. The dealer diagnosed the vehicle and determined that a hose on the transmission had not been installed correctly. The vehicle was repaired; however, the failure reoccurred two more times, and the vehicle was returned to the same dealer. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 99,000.

While driving on a highway at approximately 70mph, attempted to pass a slower vehicle. I accelerated and the vehicle dropped down in gear, started shuddering, lost power and the MIL light started flashing. I pulled to the side of the road and the vehicle shifted into another gear and seemed to operate normally. Vehicle is currently at the Ford dealership, where they say that I need a new transmission, due to the CDF drum failure.

Ongoing problem already had 2 repairs done to transmission. Gears o not shift properly when the gears go from 3-4 and 6-7. If I am not careful when I press on the gas and try to accelerate it does not shift gears and gets stuck on and my truck will not move more than 5-10 mph while I am trying to get on the highway at times with trailers coming full speed ahead behind me. I have reported this issue many times. There has been no remedy. The gears get stuck and make a jerking motion and movement causing truck to slow and barely move. It is not just a one time thing so I cant give a specific date as it happens often.

Recall issue with Catalytic converters causing check engine light to come on. I took in for recall to reset check engine light. Repair did not do anything to vehicle as check engine light comes on for a few days and goes away for a few days and the cycle repeats up until this day it continues to happen. When they did the reset Ford let me know that they reset the check engine issue for recall but I would have to pay about $5k for getting new converters if I wanted to because light would still be one since it was diagnosed that converters were bad.

The transmission is consistently hesitating to switch gears, very jerky gear shift, and will sometimes completely fall out of gear. You could so easily lose control if this happened on the highway. Thank goodness we weren’t on a busy street. This isn’t the first reporting according to a simple search online and there should be a recall for safety reasons. This could be life or death for someone driving on the highway.

Transmission has extremely hard downshifting which has required the tea be replaced. Vehicle will downshift so hard it feels like you have been rear ended. Vehicle has to be put into neutral and then back into drive. This is very hazardous.

The contact owns a 2020 Ford Expedition. The contact stated while driving 70-75 MPH, the transmission was shifting hard and unintendedly shifted to various gears continuously. The power train warning light was illuminated. The message "Power Train - Engine Failure - See Owner’s Manual" was displayed. Additionally, there was an abnormally loud sound coming from the transmission assembly. The message "Reduced Engine Power“ was displayed, and the vehicle failed to respond upon depressing the accelerator pedal. The temperature gauge displayed 285 degrees. The contact was able to veer to the side of the road and allowed the vehicle to cool down. The contact was able to continue driving. The vehicle was taken to the dealer, where the transmission yoke was replaced; however, the failure recurred several times while driving. The vehicle was taken to Red McCombs Ford (8333 I-10, San Antonio, TX 78230) and to Griffith Ford Seguin (1880 I-10, Seguin, TX 78155); where the transmission was replaced and rebuilt several times; however, the failure persisted. The contact stated while driving 75 MPH, the transmission was shifting hard and was continuously shifting from high gear to low gear. The check engine warning light and several unknown warning lights were illuminated. Another driver honked and drew the contact's attention. The contact noticed a trail of white smoke and that there was smoke coming from the engine bay. The contact was able to veer to the side of the road and allowed the vehicle to cool down. The vehicle was taken back to the first dealer to be diagnosed. The vehicle was not yet diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that they could no longer assist in covering the cost of the repair. The failure mileage was approximately 20,000.

The contact owns a 2020 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle briefly jerked and hesitated, prompting thee contact to pull over to the shoulder of the roadway to turn off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The service engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 105,000.

Hard shifting, and loss of sudden power while traveling. Recently purchased. No recalls yet. But having same issue's stayed on law site filed. vehicle lost power while accelerating to merge onto freeways or cross busy intersections.

Traveling on the highway I lost all acceleration, the gas pedal wasn’t functional and the vehicle begins to quickly decelerate, then it corrects itself and accelerates quickly. It has done this a few times already.

Already submitted 2 prior complaints regrading Transmission/Engine NHTSA ID 11583360. Vehicle transmission failure. Vehicle is at Ford Dealership for repairs. Safety risk involved risk of accident. Problem has been reproduced and confirmed by Ford service advisor. Vehicle is currently at dealership waiting on repairs to be made. It has been inspected by extended warranty advisors and approved for repair. Vehicle does give any warning when engine/transmission failure occurs. This has been documented since I bought the vehicle in Sept. 2022 with the dealership. This is the 3rd or 4th time it has gone into be checked finally when it happened and dealership was able to reproduce they stated that transmission needs to be rebuilt or new one needs to be installed. Since warranty did not want to cover new transmission they are going to rebuilt it. Before this instance they said it was because transmission failure due to having some sensor reset which did not work.

Transmission slip in 4A and above gear 4 at speed..hesitation at speed accelerating inconsistent, clunking/jerking from park to reverse when parked. 22’s have lawsuit…don’t understand why 20’s aren’t included. Need recall

Shifting of the gears when going from 1 through 10. Hard shifts between 2-5. Skipping 2 and 5 gear sometimes. Will not shift smooth between 7-8 sometimes. Starting grinding for no reason. RPM's will shout up and not catch a gear. Engine temperature has been running at over 220+ and it grinds when its at 223+ degrees. Powertrain issues of no power. Have taken to 2 ford dealers. One said that they would have to get into transmission to find problem. Other one said that the it would need a new transmission, as it had metal in it. I do not have receipts in front of me right now but can get them if needed.

Twice I have gone to accelerate and have no power. It shoots the vehicle into a fault and creates a high rpm and feels like it’s missing gears or that it didn’t shift. Both times have been close to getting us killed. Just a matter of seconds of getting hit by a semi. The other time it did it when turning through a stop light with a car coming head on. I believe it has to do with the transmission, but they don’t find anything wrong with it when they do a diagnostic. My life matters and so does everyone else that is in a vehicle. Please issue a recall on the 2020 ford expeditions to help find out why this happens.

On an express way on multiple occasions when I’ve tried to accelerate, the transmission disengaged completely. I was moving in traffic going 70-85 mph with no power to accelerate or maintain speed until the rpm hit 1000 and speed dropped below 45mph. Other times when going from park to drive or reverse the car will “clunk” and jerk like i was driving a stick shift and missed the mesh point to get into gear.