2003 Ford Explorer Power Train

THE PROBLEM WHEN YOU DRIVING ON THE HIGHWAY AROUND 65 MPH YOU FEEL THE TRUCK HESITATING, SINCE THIS TRUCK DID NOT COME WITH DIP STICK TO CHECK THE TRANSMISSION FLUID, IT IS HARD TO CHECK UNLESS YOU TAKE IT TO A TECH OR STOP ON THE MIDDLE OF THE ROAD TO CHECK IT UNDERNEATH THE TRUCK RUNNING TRANS FOR THE FLUID TO DRIP, IT IS REALLY STUPID YOU CAN BE RUN OVER BY A CAR OR CAUSE AN ACCIDENT, IT SEEMS LIKE THE MANUFACTURES ARE GETTING STUPID, IN A EMERGENCY AND YOU ARE IN THE HIGHWAY CROSSING THE STATE LINE HOW CAN YOU CHECK THE FLUID ON TRANSMISSION, IT NEED IMMEDIATE ATTENTION TO ADD THE DIP STICK PRETTY PRONTO, IT NEED THE FORD COMPANY TO TAKE RESPONSIBILITY TO ADD THE DIP STICK, I SUBMITTED SEVERAL REPORTS TO THEM THEY DON'T CARE AT ALL. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE OVER DRIVE LIGHT ILLUMINATED AND THE VEHICLE LOST ACCELERATION POWER WHILE TRAVELING VARIOUS SPEEDS. THE CONTACT ALSO MENTIONED THAT A GRINDING NOISE WAS HEARD. THE LOCAL MECHANIC PERFORMED A DIAGNOSTIC BUT WAS UNABLE TO LOCATE A FAILURE CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 185,697.

LOCKED UP AND FAILED CAUSING ACCIDENT. *TR

TRANSMISSION FAILURE AT 77,000 MILES, JUNE 2010. REPLACED WITH FORD PART AT FORD DEALER. REPLACEMENT TRANSMISSION LASTED 3 YRS/8 MOS, AND LASTED 45,000 MILES (8 MONTHS BEYOND WARRANTY). FORD WILL NOT ACKNOWLEDGE THE PROBLEM, OR PROVIDE ANY RELIEF WHATSOEVER IN RESOLVING THE PROBLEM. TRANSMISSION FAILURE AT ANY POINT, AT ANY TIME, COULD BE VERY VERY DANGEROUS. *TR

FLASHING O/D OFF, CHECK TRANSMISSION, AND CHECK ENGINE LIGHTS WENT ON. TOOK TO TRANSMISSION SERVICE CO FOR INSPECTION. THERE RESPONSE WAS THIS MODEL FORD TRANSMISSION WAS NO GOOD. THEY FLUSHED SYSTEM, ADDED NEW FLUID AND ASKED THAT I PRAY FOR EXTRA MILES. THAT WAS NOV.'13. NOW FEB '14, TRANSMISSION LIGHTING SAME CHECK LIGHTS. TOTAL RE-BUILD LIKELY AT $2500 +/_. COMPLAINTS ON 2003 EXPLORERS AT CARCOMPLAINTS.COM ARE EXTREMELY OUT OF CONTROL SIGNALING SOMETHING WRONG. PLEASE INQUIRE ABOUT THIS DEFECT AND THE 2003 EXPLORER IN GENERAL. *TR

TRANSMISSION FAILURE TOOK TO DEALER ,THEY REBUILT IT.TOOK IT BACK 04/28/05 THEY REBUILT IT AGAIN WITH 27998 MILES ON IT. TOOK IT BACK 08/23/05 WITH 31714 MILES THEY REBUILD IT AGAIN. TOOK IT BACK 02/11/08 BEFORE EXTENDED WARRANTY ENDED ON 02/19/08 THEY SAID COULDN'T FIND PROBLEM .I THINK BECAUSE OF THE LEMON LAW. NOW 12 /17/2013 IT NEEDS ANOTHER TRANSMISSION. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH WHEN THE TRANSMISSION BEGAN TO SLIP GEARS. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM AND INFORMED THE CONTACT THAT THERE WAS NOT A RECALL RELATED TO THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.

MY 2003 FORD EXPLORER WHILE GOING DOWN THE ROAD, I STARTED TO NOTICE THAT IT WAS A HARD SHIFT FROM 1ST TO SECOND GEAR, THE RPM WOULD GO TO ALMOST 4000RPM, THEN ALMOST SLAM INTO GEAR. MY O/D LIGHT STARTED FLASHING, AND MY CHECK ENGINE LIGHT CAME ON, WHEN I GOT HOME I RESEARCHED IT ON THE INTERNET AND FOUND THERE ARE NUMEROUS PROBLEMS WITH THE FORD TRANSMISSIONS, AFTER CONTACTING FORD THEY BASICALLY TOLD ME I WAS OUT OF LUCK THEY WOULDN'T HELP,,,, I HAVE BEEN A LOYAL FORD CUSTOMER FOR YEARS AND SO HAS THE REST OF MY FAMILY AND MY BUSINESS USES FORD VEHICLES. SOMEONE NEEDS TO RESEARCH THIS, FORD IS GETTING AWAY WITH A BIG INJUSTICE BY MAKING A SUBSTANDARD TRANSMISSION THAT IS COSTING THEIR CUSTOMS THOUSANDS OF DOLLARS. BUT ALL FORD WILL SAY IS IF THE NHTSA DECIDES TO INVESTIGATE AND SEES ITS A PROBLEM THEN THEY WILL ACT ON IT. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THE TRANSMISSION FAILED TO SHIFT GEARS. THE OVER-DRIVE AND TRANSMISSION WARNING INDICATORS WERE ALSO ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. UPON RESTARTING, THE FAILURE PERSISTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TRANSMISSION FAILURE. *TR

DRIVING ON INTERSTATE AT HIGH SPEED. O/D AND TRAMISSION LIGHTS CAME ON TRAMISSION DIED! *TR

O/D LIGHT SUDDENLY STARTS FLASHING WHILE DRIVING AT NORMAL SURFACE STREET SPEEDS OF 40 - 45 MPH. WITHIN 10 MILES, THE TRANSMISSION STARTED SLIPPING AND IT FELT LIKE THE VEHICLE WAS LABORING; MY WIFE THOUGHT THE EMERGENCY BRAKE WAS ENGAGED. SHE NEVER MADE IT HOME - WITHIN MINUTES, THE VEHICLE SLOWED, WOULD NOT ACCELERATE AND SUBSEQUENTLY BROKE DOWN. THE VEHICLE WAS TOWED TO THE NEAREST FORD DEALER WHO DETERMINED THE TRANSMISSION WAS A TOTAL LOSS. WE PURCHASED THE EXTENDED WARRANTY WHEN WE OBTAINED THIS VEHICLE FROM SAID DEALER. ALTHOUGH WE HAD WELL OVER 10,000 MILES LEFT ON THE WARRANTY, IT HAD EXPIRED LESS THAN 4 MONTHS AGO SOLELY BASED ON CALENDAR DAYS!! THIS IS A SECONDARY VEHICLE FOR US AND DOES NOT GET A LOT OF USE; LESS THAN 10,000 MILES A YEAR. BOTH THE DEALER PERFORMING THE REPAIRS AND FORD MOTOR COMPANY CUSTOMER CARE WERE SURPRISINGLY UNSYMPATHETIC TO THE CIRCUMSTANCES AND WERE UNABLE (OR UNWILLING) TO MAKE ANY CONCESSIONS. SO, $4,200 AND A WEEK LATER, I HAD A 'NEW' RE-MANUFACTURED TRANSMISSION. I WAS SOMEWHAT SUSPICIOUS OF THE SEALED TRANSMISSION - ONE THAT DOES NOT HAVE PROVISIONS TO MONITOR THE TRANSMISSION FLUID - WHICH WAS MANUFACTURED AND INSTALLED ON THE 2003 MODELS. AFTER LOOKING INTO THIS ISSUE, IT HAS BECOME QUITE APPARENT THAT THERE HAS BEEN AN INORDINATE NUMBER OF THESE TRANSMISSION FAILURES ON SIMILAR VEHICLES. I EXPECT TO GET AT LEAST 150,000 MILES FROM MY AUTOMOBILES - AND I HAVE WITH A FEW OTHER VEHICLES FROM ANOTHER US MANUFACTURER. CONSUMERS WHO USE THEIR HARD EARNED MONEY TO PURCHASE US MANUFACTURER'S PRODUCTS SHOULD EXPECT A REASONABLE AMOUNT OF QUALITY, RELIABILITY AND CUSTOMER SERVICE. IT IS VERY UNLIKELY THAT I WOULD CONSIDER FORD FOR MY NEXT AUTOMOBILE PURCHASE. MILEAGE AT FAILURE: 111,846. *TR

I WAS DRIVING DOWN I-10 AT 3:30 IN THE AFTERNOON ON MY WAY HOME AND MY 2003 FORD EXPLORER OUT OF NO WHERE WENT IN REVERSE I WAS ABOUT AN INCH AWAY FROM HITTING THE CAR BEHIND ME. MY CHILDREN WERE CRYING SCARED AND I TOO WAS SHAKING TRIED TO MAKE IT HOME BUT MY CAR WOULDN'T GO PAST 20MPH AND WE GOT STUCK AT THE GAS STATION HAD TO GET TOWED TO MY HOUSE. I HAVE BEEN TOLD THAT I NEED A NEW TRANSMISSION AND CANNOT AFFORD ONE I JUST BOUGHT THE CAR A YEAR AGO. THANK YOU FORD FOR ALMOST KILLING ME AND MY CHILDREN! *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE OVERDRIVE AND CHECK ENGINE TRANSMISSION WARNING LIGHTS BOTH ILLUMINATED UPON STARTING THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT NO CAUSE FOR FAILURE WAS FOUND. THE VEHICLE WOULD ALSO JERK AND LUNGE FORWARD WHEN THE CONTACT WAS DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 154,615.

THE VEHICLE WAS DRIVING DOWN THE HIGHWAY WHEN SUDDENLY THE O.D OFF LIGHT STARTED FLASHING. WHEN IT APPROACHED LOCAL STREETS I NOTICED THE TRANSMISSION WAS SLIPPING GOING INTO 2NG GEAR. THE VEHICLE WAS TAKEN TO THE DEALER WHO IMMEDIATELY DIAGNOSED IT AS A DEFECTIVE TRANSMISSION. A LITTLE RESEARCH ON THE 03 EXPLORER TRANSMISSION INDICATED IT WAS A 5R55S MODEL WHICH HAS AN ASTRONOMICAL FAILURE RATE. ITS ALSO A SEALED UNIT WHICH DOESN'T HAVE A DIPSTICK TO CHECK THE FLUID LEVEL OR CONDITION ( BURNT SMELL). THE FORD EXPLORER ALSO LEADS THE LIST BY HAVING 4 OUT OF THE TOP TEN VEHICLE COMPLAINTS FOR WORST MODEL YEARS CARS. ALL THE TOP COMPLAINTS ARE FOR TRANSMISSION FAILURE. *TR

UNEXPECTED TRANSMISSION FAILURE. TRANSMISSION NOT SHIFTING GEARS PROPERLY. VEHICLE IN GOOD CONDITION NO FLUID LEAKS. VEHICLE DRIVEN AND MAINTAINED PROPERLY. THIS ISSUE HAS OCCURRED TO NUMEROUS EXPLORER OWNERS WITH LOW MILEAGE AS MY VEHICLE. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THE OVER-DRIVE LIGHT ILLUMINATED WHILE DRIVING 65 MPH AND THE VEHICLE SLOWED DOWN TO 20 MPH. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER STATED THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE CONTACT DID NOT REPLACE THE TRANSMISSION. THE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE TRANSMISSION SLIPPED AND CAUSED THE OVERDRIVE LIGHT TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER. THE FAILURE WAS LOCATED AND THE CONTACT WAS ADVISED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE REAR HATCH FRAME WAS ALSO FRACTURED AND CAUSED THE REAR HATCH TO SPLIT IN HALF. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 112,000.

WITHOUT ANY PRIOR INDICATION OF AN ISSUE, THE OVERDRIVE LIGHT STARTED FLASHING. AFTER STOPPING AT THE NEXT TRAFFIC LIGHT, IT APPEARED THE TRANSMISSION WAS HAVING A PROBLEM GETTING INTO 2ND GEAR. NEEDLESS TO SAY, THE TRANNY PROBLEM CONTINUED AND NOW NEEDS TO BE REPLACED. THIS ISSUE SEEMS BE CONSISTENT WITH THAT OF MANY, MANY EARLY 2000S EXPLORER OWNERS. I FEEL AN INVESTIGATION INTO THIS ISSUE IS WARRANTED. *TR

CHECK TRANSMISSION INDICATOR ON IN INFORMATION CENTER AND OVERDRIVE LIGHT ON. GRINDING NOISE FROM UNDER VEHICLE. *TR

I WAS DRIVING DOWN TX HWY 190, AND MY O/D LIGHT STARTED FLASHING ON MY 2003 FORD EXPLORER, IT WAS FOUND THAT THE SHIFT SOLENOID PACK WAS GOING OUT, IT WAS AN ELECTRICAL ISSUE WITH THE SOLENOIDS, THE PACK WAS REPLACED AND NOW IT IS DOING IT AGAIN, RAN THE DIAGNOSTICS ON IT AND IT IS THE EXACT SAME PROBLEM, THE SHIFT SOLENOID PACK ELECTRICAL PROBLEM ON A SOLENOID PACK THAT IS BARELY A YEAR OLD AND THE MILEAGE IS NOW AT 201000. *TR

TRANSMISSION FAILURE. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE OVER DRIVE LIGHT ILLUMINATED AND THE VEHICLE SHIFTED ERRATICALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 96,706.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE TRANSMISSION SHIFTED GEARS INDEPENDENTLY WITH THE ILLUMINATION OF THE OVER DRIVE INDICATOR. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM AND INFORMED THE CONTACT THAT THERE WAS NOT A RECALL RELATED TO THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 136,000.

TRANSMISSION IS NOT SHIFTING INTO SECOND GEAR AND OVERDRIVE. OVERDRIVE LIGHT FLASHES. PREVIOUS OWNER HAD A NEW TRANSMISSION PUT IN THROUGH FORD MOTOR COMPANY AND IT STARTED OCCURRING AGAIN WITHIN A WEEK OF THE REPLACEMENT. I PURCHASED THE VEHICLE IN APRIL AND HAVE HAD IT TO NUMEROUS REPAIR SHOPS FOR TRANSMISSION FILTER CHANGES AND TUNE UPS, NOTHING HELPS. NOW IM TOLD IT NEEDS A NEW TRANSMISSION. THE TRANSMISSION IN IT NOW IS ONLY 8 MONTHS OLD. IT REVS REALLY HIGH AFTER FIRST GEAR THEN KICKS INTO SECOND ONLY AFTER LETTING OFF THE GAS AND MANUALLY SHIFTING WITH THE SHIFTER. IT WILL NOT SHIFT INTO OVERDRIVE AT ALL. THE OVERDRIVE OFF LIGHT IS CONSTANTLY FLASHING. I HIGHLY DOUBT MY NEXT VEHICLE WILL BE A FORD!! *TR