2019 Ford Ranger UNKNOWN OR OTHER

he 2019 Ford Ranger the VIN [XXX] , the driver’s side AC only blows hot due to the climate control issue addressed in Fords service bulletin SSM 51313. This is a known issue with the early production model of the Ranger, hence the service bulletin SSM 51313. It is my belief that faulty parts were used on the early model Rangers and instead of a recall or extending the warranty on this issue only issued a service bulletin was put out. I am writing to have the Ford MOCO issue the proper recall or cover repairs under and extended warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2019 ford ranger, 74,000 miles On way to pick up girlfriends engagement ring…. The truck started jerking, loosing power, no engine light came on. Turned around to go home and drive about 8 miles under 45 mph.Then truck started jerking again , like transmission issue. Engine light and tool wrench came on. As I was pulling in driveway, truck went into “limp” mode. Had it towed to Gullo Ford Conroe. Now they are saying need new transmission due to Internal transmission failure! Shouldn’t Ford. Over this! Only 60,000 mile warranty.

I started hearing a ticking sound under the dash on the driver's side. Then it would blow hot air on drivers side and cold air on passenger side whether it was on heat or air conditioning. We also smelt plastic once in awhile. I took it in and was told it was it was the actuator. They replaced that and that took care of the noise but not the 2 different air Temps. Took it back and now was told the distribution housing needs to be replaced. I have read on a recall for the HVAC system it could catch on fire so the melting plastic smell concerns me.

Repeated failure of HVAC system, even after repairs, leads to not only a very cold truck in January in Maine, but inability to defrost the windshield and keep it defrosted. Repairs have been made in January 2025, April 2025, and now has to be repaired again in December 2025. My independent service provider who subscribes to OEM Ford subscriptions, was not made aware of an "internal" service memo until now. Neither from the subscription services or from contacts at a Ford dealer where he resourced parts and repair info. SSM 51313 indicates a different repair than was made on the previous two attempts. These repairs require the disassembly and reassembly of the instrument panel and are very expensive - especially when not apprised of correct. Now the SSM indicates a complete housing replacement to correct the defective part. See attached forms.

When I use my back up camera it either goes all black or is distorted to the point where I cannot see what is behind my truck. This occurs randomly when I put the truck in reverse.

The transmission in my truck has worked excellently with no sign of wear or degredation in performance, that was until the transmission suddenly began hesitating and slamming into gear. This is a common problem with this vehicle and is reported online incredibly frequently, while this may seem like a simple mechanical issue it did cause a completely lost of power when making a left hand turn which nearly caused me to be T-bone'd by oncoming traffic, and the hard shifting makes throttle response incredibly unpredictable. Please help us with this, there are recalls on the transmission in these trucks in multiple other countries with the chance of death as a consequence being openly stated. Me and my loved ones were almost killed because of this transmission which has widespread problems and NEEDS to be recalled before someone does lose their life. Ford has claimed this to be due to the adaptive learning software in the truck, but coincidentally has also redesigned a critical component in the transmission that causes these types issues three times now, but with zero effort to notify the customer of the risk or to openly address the problem.

Apparently the heater box in the 2019 Ranger is prone to warping. This leads to malfunctions in the heat/ac in the cabin. They tell me if I don’t get it replaced I could wind up getting ac instead of heat. This would be a real problem in winter weather, as I may not be able to keep the windshield clear without heat. I saw many complaints about this happening to owners of the 2019 Ford Ranger. The fix is to remove the dashboard to install a new box at a cost of 2200.00, according to the Ford dealership I bought the truck from.

Ticking sound when i turn off vehicle. Usually did it for about 5 seconds, Now it just keeps on ticking and sounds like it is coming from behind glove box area passenger side. Found a lot of same complaints for this year Ranger and they mention the "Blend Door". If so many complaints shouldn't it be a recall?

2019 Ford Ranger air conditioning compressor failed. When compressor seized, the component smelt of burning. The compressor failure has been confirmed by the Ford dealership. There was no warnings prior to the problem occurring. Similar recalls have been made on other 2019 Ford Rangers.

The air conditioner blows hot air on the driver's side and cold air on the passenger side. No safety issues. It has not been verified by a dealer. We notified them a year ago. No warning lights.

The front passenger door mechanism failed. the actuator that grips onto the metal latch on the truck's frame is locked in the up position, preventing the door from closing. That creates a safety problem because the door will not close or latch.

I was slowly pulling forward, parking my vehicle. I pressed the brakes and they did not engage. I pumped my brakes and my foot was down to the floor with no brake activity and an involuntary acceleration occurred causing me to crash into a brick wall. Fortunately, I was the only person injured in the crash. The police were called and my vehicle was towed to be repaired. It was inspected by my insurance company. I called Ford several times to ask that the vehicle be inspected by a Ford investigator to determine why the brakes failed and the involuntary acceleration occurred. They misdirected me at least 10 times. I informed that there were 12 reports of the identical problem happening to other 2019 Ford Ranger owners. They ignored my requests. Upon recommendation by Ford Customer Service, my car was towed from a body shop to a Ford dealer where they informed by that there was at least one instance that the diagnostics showed a sensor failure. At no time did any warning light appear on my dash signaling me there was an issue of a sensor failure. In spite of this problem, Ford continues to ignore my request for an inspection of the vehicle. I went to a Doctor as I had a very bad headache and pain throughout my body. I had a concussion and soft tissue damage along my right side, both hands and elbows.

I am certain my vehicle does not shift correctly. It often seems to be in the wrong gear for the terrain and according to the dashboard seems to skip gears. Also it seems to not get the power to the road as if the transmission slips. It is intermittent. The start stop feature which I usually turn off, sometimes does not work correctly. I have only had this vehicle for about 5 months. When the start stop feature is off the vehicle still acts as if its on. I have read blogs of many people having similar transmission issues. A local Ford dealer told me it drove fine, nature of the beast and it shifts that way to save fuel. Also on off the gas there is a hard clunk which seem to harsh. I feel like at some point something is going to fail.

PURCHASED A 2019 FORD RANGER IN JUNE 2020. IN JULY, I NOTICED THAT THE IGNITION TRIM RING BEZEL, A PART TO SECURE THE IGNITION CYLINDER TO THE STEERING COLUMN WAS MISSING AND THE CYLINDER COULD POSSIBLY DETACH. I CONTACTED THE DEALERSHIP TWICE AND HAVE NO RESPONSE.