2012 Hyundai Santa Fe ELECTRICAL SYSTEM,ENGINE

In November 2024, my car engine failed. I came out of a store, turned key, all the dash lights lit up, and loud clanging but unable to drive. Car towed several times and told by 2-3 places the engine was “out” and there was a Hyundai recall aon 2012 Santa Fe. A Hyundai dealer had my vehicle, contacted Hyundai and was told it “wasn’t in recall.” Had to pay repair entirely myself on disability income. The vehicle subsequent to this had electrical problems and the car shut off while driving countless times, even highway doing 65-70. Paid for alternator twice and new battery, two battery jump boxes, and car continues to have severe electrical issues and highly unsafe to drive. I am broke and facing losing the car altogether and suffered lack of housing for 2 months and inability to pay my bills. All invoices are not included with this complaint.

Purchased this used 2012 Santa Fe directly from Hyundai last January (2023) We have had to continually fill it up with oil. Two months ago, driving to work and the car stops accelerating and felt like the “power was going out”. I was on a busy highway early in the morning when it died on me. Took it to a nearby mechanic and it threw engine failure pins. There was no oil so we added more oil and it drives but will not exceed 50 mph and goes out at any given time.

coincidentally after 11-months after a software update for that knock sensor now I do have a problem with that knock sensor by having to be replaced. Total cost of repair: $643.90 (Vehicle broke down, my SUV went into limp mode meaning loss of power/acceleration, I needed a tow. The engine malfunction indicator light in the dashboard was blinking on & off.)

WHEN DRIVING THE VEHICLE, THE VEHICLE WILL LURCH FORWARD. THIS COULD BE DONE AS I AM ACCELERATING, AS I AM BREAKING, OR AS I AM COASTING. THE DASHBOARD LIGHTS WILL THEN ALL COME ON INCLUDING THE CHECK ENGINE LIGHT. THE VEHICLE WILL START TO SHAKE AND UNABLE TO ACCELERATE. FORCING YOU TO PULL OFF AND PARK THE VEHICLE. WHEN YOU TURN THE VEHICLE OFF AND TURN IT BACK ON IT'S LIKE NOTHING EVER HAPPENED. THE VEHICLE HAS ALSO HAS INSTANCES WHERE THE RPM GAGE REGISTERS ZERO, EVEN AFTER YOU ARE ACCELERATING. WE HAVE HAD THE SPARK PLUGS REPLACED, THE FUEL SYSTEM LINE CLEANED OUT, WE STARTED NOTICING THE PROBLEM IN FEBRUARY IS 2020 AND THE FREQUENCY OF THE PROBLEM HAS ONLY INCREASED. THIS NOW HAPPENS ABOUT EVERY 3-4 DAYS. I HAVE 2 CHILDREN AND I DO NOT FEEL SAFE DRIVING IN THIS CAR WITH THEM. I BELIEVE THAT MY VEHICLE SHOULD BE A PART OF THE RECALL NUMBER 20V746000, OR FROM HYAUNDAI'S RECALL NUMBER 198.

THE VEHICLE STOPS RUNNING IN THE ROAD WITHOUT WARNING AND IS UNABLE BE RESTARTED. ATTEMPTS TO CHARGE THE BATTERY FAIL. WHEN TAKEN TO BE EVALUATED BY THE BRAND DEALERSHIP, THEY ONLY CHANGE THE BATTERY AND SAY THAT IT HAS BEEN FIXED. WITHIN 3-4 WEEKS, IT WILL SHUT DOWN IN THE ROAD AGAIN. THIS HAS OCCURRED FOUR TIMES, AND EACH TIME, I TAKE TO BE SERVICED AND THEY ARE UNABLE TO REPRODUCE THE FAILING ISSUE. I HAVE REACHED OUT TO CORPORATE, AND HAVE QUICKLY DISMISSED MY CASE. THERE WAS A CLASS ACTION LAWSUIT IN 2016 CONCERNING THE EXACT ISSUES I AM EXPERIENCING WITH THE VEHICLE. I WOULD THINK WITH THIS TYPE OF DOCUMENTED LIABILITY, THERE WOULD HAVE BEEN A RECALL ON THE VEHICLES OR A WARNING NOTICE DEALERSHIPS WERE REQUIRED TO PRESENT WITH THE SALE. I DO NOT FEEL COMFORTABLE TRADING THE CAR IN AS THE ISSUE WILL BE TRANSFERRED TO ANOTHER CONSUMER.

TL* THE CONTACT OWNS A 2012 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ALTERNATOR AND ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE DEALER AND THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. *BF CONSUMER STATED ENGINE WAS REPLACED.*JB

AFTER DRIVING TO WORK (APPROXIMATELY 27 MINUTES AT SPEEDS UP TO 70+) I PULLED INTO MY WORK PARKING LOT LIKE I HAVE DOWN THOUSANDS OF TIMES BEFORE. I PROCEEDED TO MAKE A RIGHT TURN AND ALL POWER FAILED ON VEHICLE. THE RADIO DISPLAY WENT DEAD AND THE CAR STOPPED MID TURN. IT WAS ALMOST LIKE WHEN YOUR POWER GOES OUT AT HOME DURING A STORM. I TRIED SHIFT THE CAR TO SEE IF IT WOULD WANT TO START BACK UP BUT IT DIDN'T LET THE KEY GO ALL THE WAY TO THE RIGHT LIKE YOU WOULD TO NORMALLY CRANK A VEHICLE. THE PANEL ILLUMINATED ALL ICONS AND LIGHTS (SIMILAR TO A POWER OUTAGE). I TRIED TO START THE CAR A FEW MORE TIMES WHEN FINALLY IT TURNED OVER AND I PULLED TO THE NEAREST PARKING SPACE. I IMMEDIATELY CALLED THE DEALERSHIP AND EXPLAIN WHAT HAPPENED. I HAD ROADSIDE TOW IT TO THE DEALERSHIP (SPORT DURST). AFTER HAVING THE VEHICLE ALL DAY, I ARRIVED THERE SLIGHTLY BEFORE 5PM TO DISCUSS WHAT WAS FOUND. THEY PROCEEDED TO SHOW ME A PRINT OUT OF THE COMPUTER READING WHERE IT HAD NO "CODES" PRESENT. I WAS THEN TOLD IF THEY DON'T HAVE A CODE, THEY DON'T KNOW WHERE TO LOOK FOR THE ISSUE. I THEN EXPLAINED THAT I WAS LUCKY THIS TIME THAT I WAS NOT IN TRAFFIC OR THAT ANOTHER CAR WASN'T BEHIND ME OR THAT IT WASN'T AT NIGHT IN AN UNSAFE AREA BUT AS A CAR OWNER WHY AM I EXPECTED TO ROLL THE DICE WITH MY SAFETY?? WHY CAN'T THEY DO WHAT IT TAKES TO GET TO THE BOTTOM OF THE ISSUE. I DON'T LIKE BEING AT ANY DEALERSHIP WASTING MY EVENING HAGGLING WITH THEM MORE THEN THEY DO. THEREFORE I HAVE NO REASON TO MAKE IT UP. THE SERVICE MANAGER TRIED TO EXPLAIN THAT HIS HANDS WERE TIED AND THAT FOR THE WARRANTY TO BE USED TO CHECK ALL POTENTIAL ISSUES (WITHOUT ANY "CODES") I WOULD HAVE TO BE RESPONSIBLE FOR THE BILL UNLESS THEY FIND SOMETHING WHICH I FEEL IS UNFAIR WHEN THE CAR IS 2 YEARS OLD WITH 40,000 MILES. I WAS THEN TOLD WHEN IT HAPPENS NEXT TIME... RECORD IT... *TR

THIS IS THE FOURTH TIME SINCE THE PURCHASE IN APRIL, 2012. THE ENGINE JUST SHUTS OFF WHILE DRIVING NORMALLY AT A LOW SPEED. THE DEALER SHOP OBVIOUSLY COULD NOT FIND ANY ISSUES. I CANNOT UNDERSTAND WHY THIS TYPE OF HIGHLY DANGEROUS PROBLEM IS NOT BEING ADDRESSED BY NHTSA URGENTLY. I SEE THAT THERE ARE OTHER COMPLAINTS OF THIS NATURE REPORTED. I CANNOT BELIEVE THAT I HAVE TO RISK OUR FAMILY LIVES TO PROVE THAT THERE IS A SERIOUS FAULT WITH THIS VEHICLE! *TR

AT 2 TIMES IN THE LAST FEW MONTHS THE CAR ENGINE HAS SUDDENLY STOPPED WHILE DRIVING SLOWLY ON LEVEL GROUND. LOST POWER STEERING AND POWER BRAKES. CAR RESTARTED IMMEDIATELY. SO FAR DEALERSHIP UNABLE TO REPRODUCE OR HELP WITH PROBLEM. *TR

VEHICLE STALLED AS TURNING INTO DRIVEWAY OF SHOPPING COMPLEX. THE STEERING WHEEL FROZE AS I WAS TRYING TO TURN LEFT. IN THE DASHBOARD, NO LIGHTS ON EXCEPT "MALFUNCTION INDICATOR" LIGHT WAS LIT. RESTARTED CAR AND DROVE ON, THE "MALFUNCTION LIGHT" GOT TURNED OFF, CAME HOME AND THEN CALLED DEALER. DROVE TO DEALER BUT THEY COULD NOT DIAGNOSE THE ISSUE SINCE THE LIGHT WAS NOT ON AND SO NO CODE CAN BE FOUND. CAR IS LESS THAN 3 MONTHS OLD AND NOT EVEN 3000 MILES ON THE CAR. I FEEL THIS CAR IS NOT SAFE UNLESS HYUNDAI TAKES CARE OF THE PROBLEM. NOT DIAGNOSING AND ADDRESSING THE ISSUE MAKES ME CONCERNED. IF CAR STALLS WHILE DRIVING THEN THAT IS VERY DANGEROUS AS IT CAN CAUSE AN ACCIDENT SUCH AS CAR HITTING FROM BEHIND. I AM VERY MUCH CONCERN WITH SUCH A PROBLEM FOR CAR AS NEW AS MINE. *TR