2018 Hyundai Tucson Engine

My 2018 Hyundai Tucson experienced sudden catastrophic engine failure when a connecting rod threw while driving. The engine burned through its oil and the vehicle became inoperable. Hyundai denied warranty coverage for this engine failure because I had not completed the 2021 KSDS (Knock Sensor Detection System) recall. I was never notified of this recall. The KSDS recall is a software update intended to detect engine knock. It does not prevent mechanical engine failure. Denying warranty coverage due to a software update that I was unaware of raises safety concerns, as engine failure can occur suddenly while driving and creates risk of crash or injury. This appears related to known engine issues in Hyundai vehicles. I am concerned this is a broader safety defect affecting other consumers.

The contact owns a 2018 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The vehicle was pulled over to the shoulder lane, engine oil was added, and the contact waited for several minutes for the vehicle to return to normal operation. There was no warning light illuminated. The vehicle was taken to be diagnosed; however, the dealer was unable to determine the cause of the failure. The dealer suggested that the contact occasionally add oil to the vehicle. The vehicle was not repaired. The contact stated that while the accelerator pedal was depressed, there was an abnormal sound coming from the engine compartment. The vehicle was taken back to the dealer, where it was diagnosed, and it was determined that the catalytic converter needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the catalytic converter needed to be replaced and that an oil change was needed. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 99,400.

Purchased 9/5/25 at 76,280 and oil change light shown by 10/1/25 when i received an oil change at Valvoline and was told of my engine issues at 77,733 miles. Car then looked at by Elizabeth Auto Sales [XXX] and confirmed oil consumption at no fault of my own and metal shavings in oil. Car then towed to #1 Cochran Hyundai Monroeville [XXX] and looked at by Dale. Oil change and oil consumption test started and confirmed of burning more than 1 qt per 1k miles. 2/4/2026 engine test cleaning requested and denied. Car stalls at random times can possible cause an accident. yes the problem was produced to the dealership purchased from which was Kenny Ross Subaru Irwin pa 15642. Yes the problem was confirmed by Hyundai on 11/7/25. Only warning was the oil change light flashing which forced me to get an oil change less than a month of purchasing on 10/1/25 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The engine is burning excessive oil. Down 3 quarts over approx. 3,000 miles. Mechanic verified there are no leaks - it is burning the oil.

I have experienced two near-fatal incidents involving a sudden, uncommanded loss of motive power while traveling at highway speeds (approx. 70 MPH). On February 11, 2026, the vehicle entered "Limp Home Mode" without warning, dropping speed to 60 MPH and 2000 RPM in heavy traffic. This caused an immediate and dangerous speed differential, nearly resulting in a high-speed rear-end collision. Simultaneously, the AC system disabled, indicating a severe engine protection event. Manufacturer Negligence: The vehicle was taken to Courtesy Hyundai of Tampa twice for this issue (Code P0087). They performed a "Knock Sensor" replacement and cleared data points, assuring me the vehicle was safe. The failure recurred immediately. I subsequently took the vehicle to Brandon Hyundai on February 13, 2026. Despite my reports of near-fatal highway failures, Brandon Hyundai was instructed by Hyundai Corporate to merely repeat the "Knock Sensor" replacement—a repair that had already failed to resolve the dangerous condition. Critical Safety Admission: On 02/23/2026, Brandon Hyundai Service Advisor Abel Gomez explicitly admitted that this repair is "not a fix, it is a temporary thing until it shows again," yet stated they must follow Corporate’s directive to release the car. Requested Action: Hyundai is knowingly releasing a vehicle with a recurring, life-threatening defect (P0087/Sudden Power Loss) by performing "band-aid" sensor swaps instead of addressing the high-pressure fuel system or internal engine failure. This practice is a direct violation of the Safety Act. I request an immediate investigation into Hyundai’s refusal to perform permanent repairs on GDI engines displaying these catastrophic failure codes.

I am writing this letter to formally document a series of catastrophic safety failures and gross negligence regarding my 2018 Hyundai Tucson. On two separate occasions, including as recently as Wednesday, February 11, 2026, I narrowly escaped a fatal high-speed collision because this vehicle entered "Engine Protection Mode" while traveling at highway speeds. Incident Timeline: Previous Service: I have visited Courtesy Hyundai of Tampa twice for engine-related symptoms and code P0087. They replaced the knock sensor and assured me the vehicle was safe. Safety Incident (Feb 11, 2026): While driving on the highway, the vehicle suddenly lost power, dropping to 60mph and 2000 RPM (Limp Mode) in heavy traffic. This sudden deceleration nearly caused a high-speed rear-end collision. Current Status: The vehicle is currently at Brandon Hyundai (as of Feb 13, 2026). I have been told a review will take 3-5 business days, leaving me without safe transportation or a loaner vehicle. Negligence and Liability: Courtesy Hyundai of Tampa was aware of the recurring P0087 code and engine performance issues. By clearing codes or replacing minor sensors (knock sensor) without addressing the underlying high-pressure fuel or internal engine failure, they released a dangerous, defective product onto the road. This vehicle is clearly covered under the Theta II GDI Engine Settlement and Service Campaign 966. The local dealerships are willfully avoiding a necessary engine replacement to save on internal costs, despite knowing the vehicle is prone to sudden failure. Demand for Action: Immediate Loaner Vehicle: I require a safe rental/loaner vehicle immediately, paid for by Hyundai, while my car is being inspected. Full Engine Replacement: I am demanding a full engine replacement as previously indicated by technicians should the light return. Expedited Review: I am extremely unsatisfied to be told again I have to wait "3-5 business days" for a safety-critical evaluation of a vehicle that has alre

DRIVING ON FREEWAY NO WARNING LAMPS ON DASHBOARD. EXIT FREEWAY TO GET GAS AND THERE IS MINIMAL ENGINE PERFORMANCE AND CHECK ENGINE LIGHT ILLUMINATES. CYLINDERS ARE NOT FIRING, NO COMPRESSION. ENGINE FAILURE CONFIRMED BY HYUNDAI SERVICE DEPT AND INDEPENDENT MECHANIC.

My 2018 Hyundai Tucson experienced repeated no-start conditions. The vehicle was initially diagnosed by Randy Wise Hyundai in Flint, Michigan, and I paid approximately $776 for tune-up services that did not resolve the issue. Shortly afterward, the vehicle continued to fail to start. The dealership later determined the starter had failed and provided an estimate of approximately $985 for replacement. Hyundai Motor America denied goodwill assistance and reimbursement for the prior misdiagnosed repair and stated the starter replacement is customer-pay. The vehicle’s inability to start caused loss of reliable transportation and safety concerns due to being stranded. I am submitting this complaint to document starter failure and potential diagnostic issues affecting vehicle safety.

The car began making a knocking sound on my 5.8 mile drive. On my drive home from work, the knocking was louder, and the car barely accelerated on the highway and over-revved trying to hit at least 50 mph to keep up with the flow of traffic. I took the car to the Hyundai Service Center immediately using city streets rather than the highway. I had a family member follow me to make sure I made it to the service center as well as give me a ride home after I dropped off the vehicle. As I was driving there, the car had a hard time accelerating from a stop and barely maintaining speed of the flow of traffic and the “Check Engine” light came on and flashed as I got closer to the dealer service center. The dealer service center confirmed that the engine needs to be replaced due to the connecting rod bearing failure, a common issue with the 2.0L I4 F DOHC 16 V engine in my 2018 Hyundai Tucson. The Hyundai Service Manager has repeatedly confirmed that the engine issues presented in my car are consistent with a recall for the same model engine found in my car.

There is oil that leaks on a couple spark plugs.....when I remove the plug there is oil on the plug cover and inside where the plug goes in.........disturbing.....can you help....supposed to be a recall but I don't know what to do.....I would like to get that straightened out..... I want to keep it .....also like to buy my wife a new one......can you help on this problem.... They were supposed to fix recall..... Hundai Uniontown Pa. Can you help.... [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2018 Hyundai Tucson has been experiencing oil consumption issues for over a year. It began at around 80k miles, when it should have been covered by warranty but they made me pay out of pocket for an oil consumption test only to ultimately recommend a top end cleaning, which I also paid for and it did not solve the problem. This is a known issue with Hyundai, and they have settled many lawsuits but have consistently denied any repair or solution for me. I am burning about 5 quarts of oil every week, and this is a problem they refuse to help solve.

Oil consumption, will change oil and within weeks i will be down 23 Quarts of oil

Shortly after purchase, I had an oil change and vehicle inspection performed. I was informed that my engine may have an internal defect causing it to burn oil excessively. I later took the vehicle to a AAA-approved Hyundai service center, where they confirmed that the engine is burning oil due to a known manufacturer issue and that it is not the result of owner misuse or neglect. I have been quoted approximately $11,000 for a replacement engine, which is an extreme and unexpected cost for a recently purchased vehicle in otherwise good condition.

My 2018 Hyundai Tucson SEL PLUS limited showed a flashing check engine light on 10/14/2025 and basically gave up acerating pass 60mph while I was driving , I pulled over and called the dealership where I bought it from they told me to drive it in, I did and they did an oil change and filled up, we then began the oil consumption test which I brought it back yesterday 10/24/2025 and was told the whole engine needed to be replaced due to a major oil consumption problem, they advised me to bring it the Hyundai dealership to get it fixed they rudely told me no we can't fix this, we would have to wait for it to flash the check engine light again and it would have to fail a bearings test before it can be fixed and still have a possibly of it not fixing. only confirmed by the lot I bought it from since Hyundai refused to look at it.

My 2018 Hyundai Tucson 1.6 Turbo (VIN [XXX] , 113,000 miles) burns oil excessively and was deemed to need full engine and turbo replacement ($15,382.95). Hyundai refuses responsibility (case #XXX). This is a widespread defect that causes potential loss of power while driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2018 Hyundai Tucson has excessive oil consumption. Burns multiple quarts of oil per 1000 miles. Hyundai refuses to remedy the oil consumption. Oil consumption has also led to having to replace the catalytic converter due to oil burn off.

My engine stopped and locked up. It happened while I was driving on the highway/interstate. Yes it has been diagnosed by the dealership. There was no warning lights prior to the system failure.

Component: Engine Vehicle: 2018 Hyundai Tucson VIN: [XXX] Approx. Mileage at Failure: 79,413 miles Incident Date: [XXX] Where It Happened: While driving [XXX] At 79,413 miles, my 2018 Hyundai Tucson (VIN: [XXX}) suffered complete engine failure without warning. The vehicle had been properly maintained (records from Express Oil Change & Tire Engineers), and was operating under normal conditions. The dealership diagnosed total engine failure and quoted $7,723.88 for replacement. They are not replacing the engine with the same type, which may indicate a known issue. There are no active recalls, but similar engines in Hyundai vehicles from this era have been subject to recalls and warranty extensions. I believe this may be due to a manufacturing defect. No injuries occurred, but the failure posed a safety risk while in traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The oil sensor doesn't illuminate the light on the dash when the oil level becomes low. The only warning is when it becomes really low and then the check engine light will appear. It's a safety concern due to the engine possible failure and or damage may occur at that point if continuing driving happens. This causing the engine to stall and loss of control of the vehicle. Which could lead to a vehicle crash resulting in injury or death to the occupants and or others nearby.

1.The engine is consuming oil excessively. 2 and 3. I was informed during a service visit that this is a common problem. I asked how to get it fixed and was advised to lock the engine up. I informed the service advisor that I would not lock the engine up and told him I have a [XXX] son. I told him I'm trying to do everything I can to prevent that very scenario. 4. Yes, I will provide records. Additionally, a class action lawsuit was filed in California under their Lemon Law. Do a quick google search. Everyone I have spoken to at the dealership has confirmed they are all well aware, however they can only do what corporate allows under the Warranty. I am the first and only owner supposedly covered until 100k miles. This problem began at 79k. I'm at 86k and still struggling to get anything moved forward. 5. Unknown 6. My oil light flickered briefly but never stayed on. I immediately checked to discover not a drop on the dipstick. I will provide photo. My oil has been below the low mark several times since this photo and has never come back on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1.What component or system failed or malfunctioned, and is it available for inspection upon request? Engine is failing/malfunctioning. Yes it is available upon request 2. How was your safety or the safety of others put at risk? No oil can cause an engine to overheat and/or catch fire. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the issue was confirmed by Hyundai of Medford. Oil consumption test was completed. Preauth was submitted for a new engine and was denied. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, inspected by manufacturer (Hyundai of Medford). No leaks or other issues that could cause this were found. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, no warning lamps or messages were shown or sent. Even when low on oil. Consuming oil extremely quickly. Oil change was completed and I was only able to drive 700 miles before I was low on oil. I have history of oil changes and top offs every 1000 miles for about a year. It has only gotten progressively worse. Hyundai of Medford Confirmed the issue and confirmed there were no oil leaks or other issues that could cause this. They recommended I request a new engine for Hyundai. I submitted the Pre-Authorization and it was denied. After more research I have found that thousands of people have had the same exact issue with the same year, make and model of my care. There is even an entire Facebook group dedicated to this issue. The manufacture needs to be held accountable for these faulty engines. Thousands of cars should not need a new engine before they reach 100k miles. I am writing hoping to shine some light on this issue that is effecting thousands of Hyundai owners.

Loosing oil constantly and now there is a loud noise with the engine/motor

The contact owns a 2018 Hyundai Tucson. The contact stated that while driving at 60 MPH, the vehicle lost automotive power, with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and the contact was advised that there were metal shavings found on the camshaft sensor. The contact was advised that the camshaft sensor, oil flow solenoid, and variable tee valve were faulty and needed to be replaced. The vehicle was repaired; however, the failure reoccurred 3 months later. The contact stated that while driving 60 MPH, the vehicle failed to accelerate as needed, with the check engine and oil light illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the engine was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 56,942.

The contact owns a 2018 Hyundai Tucson. The contact stated that while driving approximately 15 MPH, and slowing down to make a right turn, the vehicle almost stalled and lost power. The contact stated that the check oil warning light was flashing on and off. The contact depressed the accelerator pedal, and the vehicle failed to respond. The contact was able to pull over and shift into park(P). The contact had not turned the vehicle off. The contact called her father. The father arrived, and the vehicle was turned off. The contact stated that her father checked the oil dipstick and saw that the oil level was extremely low. The contact stated that two quarts of oil were added. The contact drove the vehicle to a local dealer. The dealer diagnosed and determined that a gasket on the oil filler tube was not correctly seated, and the catalytic converter needed to be replaced. The contact stated that prior to the recent failure with the catalytic converter, the catalytic converter had been replaced approximately 1 year and 8 months prior. The dealer also recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 102,000.

I have regular oil changes (every 3k mi) and every time I go get say there’s no or low oil. At the beginning of July my engine coil in column 3 failed and I had all four coils and spark plugs replaced. Since the replacement my engine is still consuming a quart of oil per week