2002 Mercedes-Benz C-Class Structure

Recall ID: 24V874 on Sliding Roof Bonding was issued. Mercedes-Benz of Nashville was not able to open the Roof and asked for $219.88 to determine cause of sunroof being inoperative. Recall letter stated that: "vehicle repair will be provided at no cost to you" "If dealer for any reason is unable to remedy the situation without charge.. you may submit a complaint to the NHTSA.." Hence I am submitting this complaint that my sliding roof was not checked nor repaired.

RECEIVED NHTSA RECALL #19V918, MB CAMPAIGN #2020040011, AND BROUGHT VEHICLE TO MERCEDES DEALER, ALFANO, IN SAN LUIS OBISPO, CA ON 8/25/2020. WAS TOLD BY DEALER'S SERVICE MANAGER THAT VEHICLE PRODUCTION DATE WAS NOT AVAILABLE AND THAT THE VEHICLE DID NOT MATCH THE MODELS INCLUDED IN THE RECALL, SUCH PRODUCTION DATES WERE FROM 01/16/2006 TO 07/09/2006 INCLUSIVE. NO INSPECTION OF THE SUNROOF BONDING OR REPAIRS WERE ATTEMPTED ON THE VEHICLE. IMAGE OF SERVICE INVOICE ATTACHED TO THIS DOCUMENT.

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C320. THE CONTACT STATED THAT HE NOTICED THAT CORROSION WAS DEVELOPING ON THE LOWER PANEL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE ENTIRE BODY OF THE VEHICLE WAS CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE IS 51,000. UPDATED 12/30/13*CN THE CONSUMER STATED THE VEHICLE WAS ALWAYS GARAGED AND WELL MAINTAINED, YET THE DOORS AND UNDER PANELS SHOWED EXTENSIVE CORROSION. THERE WERE SEVERAL PRONOUNCED PAINT BUBBLING AND RUST SPOTS THAT HAVE PERMEATED THROUGHOUT THE BODY.

THE INSIDE FRONT DOOR HANDLE OF C-CLASS (YEAR2002 OR SIMILAR) IS NO GOOD, IF YOU PARK THE CAR ON THE DOWN SLOPE STREET, AND CLOSE THE FRONT DOOR FROM WIDE OPEN POSITION, THE DOOR HANDLE WILL GIVE AWAY AND BROKEN APART AT THE TOP END WHICH IS ATTACHED TO THE INSIDE DOOR PANEL ONLY WITH A SMALL PLASTIC STUD. I SENT THE COMPLAINT LETTERS TO MERCEDES BENZ USA AS WELL AS MERCEDES BENZ OF SAN FRANCISCO, THEY NEVER RESPONSE. I BELIEVE THE FAILURE OF THE DOOR HANDLE TO PERFORM PROPERLY BECAUSE OF FAULTY DESIGN AND THE MANUFACTURE HAS TO BEAR RESPONSIBLE BY RECALLING THIS TYPE OF DOOR HANDLE. *TR

2002 MERCEDES-BENZ C230K ENGINE STOPPED, CAUSING EVERYTHING TO STOP FUNCTIONING. *KB THE MECHANIC FOUND WATER IN THE CONNECTOR. THE BLOCKAGE WAS CAUSING THE DRAIN TO BACK UP, WHICH WAS CAUSING WATER TO ENTER THROUGH THE ROOF. THE DRIVER SIDE DRAIN LINE WAS CLOGGED WITH LEAVES AND DEBRIS, WHICH DAMAGED SOME ELECTRICAL COMPONETS. *JB

WHILE MAKING LEFT OR RIGHT TURNS THE VEHICLE MADE A CRUNCHING NOISE IN THE INTERIOR OF THE VEHICLE. THE VEHICLE HAS BEEN TAKEN TO THE DEALER FOR REPAIRS (MERCEDES BENZ CLK55AMG 2002). *NLM

MY 2002 MERCEDES BENZ CLK 430 CABRIOLET (YOUR WEB SITE DOES NOT LIST THIS MODEL OR THE CLK 55) HAS A WARPED REAR SUB-FRAME AND THERE WAS NO INCIDENT TO CAUSE THIS. THE DEALER TOLD ME THE CAR WAS NOT SAFE TO DRIVE AND CHARGED 3000 TO FIX! *NLM