2018 Ford Fusion Power Train

CVT transmission completely failed at 150k miles and is not covered by Ford

Transmission cable shifter bushing was defective and popped off of transmission shifter. This subsequently caused the transmission control module to overwork and fail.

Car started running rough then white smoke was coming out the exhaust. Took it in to have it checked out by Ford and they said it was coolant intrusion into the cylinders. Now they want $9,000 to replace an engine that has less than 60,000 miles. I see online that this is not new and definitely a design flaw with this engine and many others.

UNKNOWN

The contact owns a 2018 Ford Fusion. The contact stated while driving 30 MPH and depressing the accelerator pedal, the vehicle hesitated and stalled. There was no warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and transferred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 72,000.

Shifter cable bushing degraded and fell off. Causing a condition where the car could not be shifted into or out of gear, and car applied park brake as a safety precaution and could not be disabled until the shifter was manually put back into park by mechanic. This bushing has been under recall for other year fusions but has not been extended to this one. Research on forums shows this is a very common problem. Could be a real safety issue if car cannot be shifted and it needs to be driven away in an emergency. This part should not fail in this short of time, it is made of inferior materials and does not last. No warnings given prior, part fails catastrophically.

The contact owns a 2018 Ford Fusion. The contact stated that after starting the vehicle, the gear shifter could not immediately be shifted out of park(P). The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was unknown.

Transmission shift linkage bushing failure and torque converter shudder shudder been on going problem for approximately 12months90000

At 68,000 miles, the transmission began experiencing symptoms of a failed transmission. I took it to the dealer and they confirmed that there was a CONCERN HARSH SHIFT ON 3RD GEAR AND DIAGNOSE DIRECT DRUM CAUSING CUST CONCERN AND SHUDDER CONCERN TORQUE CONVERTER. This diagnosis caused the vehicle to hard shift everytime i would take off and often time cause a kick on the transmission. Because of this, the rear main seal of the engine also gave out prematurely. While driving on the freeway, the engine began leaking oil suddenly from the rear main seal causing the entire bottom of the engine to get soaked with oil. This also caused the oil to fall in to the brake pads and rotors. While driving on the freeway, i lost braking power and could not stop safely. I had to pull to the shoulder and attempt to stop the vehicle. Fortunatelly, there were no cars on the soulder and was able to stop the vehicle. This is where i discovered the vehicle full of oil in the bottom of the vehicle along with the brake pads and rotors. The vehicle was towed to the house about 130 miles. Once discovered, it was taken to Sunrise Ford where they discovered all of the issues. The service tech told me that it is a common problem for those transmissions to fail prematurely and cause other problems. This is a safety issue because after 7 years of the vehicle being on the road with under 100k miles, it is posing a safety hazard not only for the customers but also the public. Please investigate the transmission issue that is leading to other safety issues. This is the 6F35 transmission that is installed on these vehicles. These transmissions are famous for failing prematurely. This was one of those cases. No check engine light comes on to indicate that there is trouble with the transmission. This problem is putting others and oneself at risk because it lead to other failed components. The problem first appeared at 55k miles and around january 2023.

The contact owns a 2018 Ford Fusion. The contact stated that after his girlfriend was occupied and parked in the residence, while attempting to reverse the vehicle the gear shifted independently into park. The contact mention he lifted the front end of the vehicle, and he noticed the shifter cable detached from the transmission shifting arm. The contact was able to attach the shifter cable on the transmission shifting arm but also noticed the shifter cable bushing has detached from the transmission as well. The vehicle was not taken to be diagnosed. The vehicle was not repaired however the contact mention the vehicle will be getting repaired on March 29th. The contact related the failure to the NHTSA Campaign Number: 22V413000(POWER TRAIN). The insurance company had not been contacted yet. The manufacturer was made aware of the failure they informed the contact that NHTSA calls the manufacture to have recalls on their VIN. The contact was referred to NHTSA to file a complaint on the failure. The failure mileage was 102.000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving 30 MPH, the vehicle hesitated, and the transmission failed to shift into third gear. The contact stated there was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 74,433.

Coolant intrusive. New motor needed

While maneuvering in parking lot car would not shift from Reverse to Drive after backing out of parking place, error on dash stated shift module failure. Tow truck driver manually engaged shifter to drive, too car to Freeman Ford. Upon inspection shifter grommet at transmission had worn not allowing car to change gears, $4 in parts, $300 in labor to fix. Fortunately the car was just blocking a post office parking lot, if this had been a maneuver in an intersection it could have caused an accident. There was no indication this failure was going to occur.

The contact owns a 2018 Ford Fusion. The contact stated that while at a stoplight, the vehicle hesitated and jerked. The contact depressed the accelerator pedal, but the vehicle hesitated and lost motive power. The service vehicle message was displayed. There was a highlighted rectangle displayed. The vehicle was taken to the local dealer, where it was diagnosed and DTC: P0218/P177S was retrieved, and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was taken to another local dealer, Academy Ford Sales (13401 Baltimore Ave, Laurel, MD 20707); where it was diagnosed that the transmission, intermittent clutch, and shaft needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic who determined that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 70,000.

Transmission issues, I had my transmission replaced right out of warranty so Ford assisted 4 grand to assist the repair because the dealership took a mmtj to get my car in, i didn't know it was going to go over the trade in program replacements in miles. The car shifts weird, in drive the vehicle acts as if it was put in neutral randomly and it jerks you hard into gear throwing you and passengers into the back of the seat a,pay got hit two times it also when you start the car, put it in drive it throws it's self back into park then you put it back into drive or reverse and it grooms and goes as if I'm accelerating which i got hit once backing out of a sppt because of this i hagea friend who has the same issues why is theee not a recall on their ford fusions or them getting sued????

My car's transmission had a "system shift error", and now it cannot be shifted into any gear besides park, and is underivable. We were stuck at a gas station and blocking traffic. The problem has not resolved, we have not brought it to a service center but we can. There were no warnings besides when it occurred, we simply could not leave the parking lot and had to be towed. The tow truck driver had to drag the car up. onto the bed because since the shifter would not work or go into neutral, he was forced to tow it in park.

The vehicle started jerking violently out of nowhere while being driven only 35 MPH. It immediately became unsafe and unable to be driven without any warning whatsoever. No lights on the dash or anything leading up to this issue. After being diagnosed we were told the transmission needs to be completely replaced. Also after doing some research we have discovered that this is a well known issue with this vehicle that has not been addressed with this year model, but was with previous model years.

The contact owns a 2018 Ford Fusion. The contact stated that after her son had placed the vehicle into reverse(R), the vehicle failed to respond when shifted into drive(D). The contact stated that the WRENCH (Transmission) warning symbol appeared on the instrument panel. The vehicle was towed to the dealer where a diagnostic test was performed. The contact was informed that the shifter cable bushing and the shifter cable bushing cap needed to be replaced. The manufacturer was notified of the failure and referred the contact to the NTHSA Hotline to report the failure. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 60,000.

The contact owns a 2018 Ford Fusion. The contact stated that the transmission independently shifted into the park(P) while driving at speeds of 30 MPH or exceeding the speed. The gear shifter had detached from the vehicle while driving over rough road surfaces. The contact had to manually maneuver the gear shifter to move the gear shifter to the desired position. The wrench symbol was displayed on the instrument panel, indicating that the vehicle needed to be serviced. The vehicle had been taken to a certified mechanic who diagnosed that the gear shifter had a detached that needed to be repaired. The vehicle had been repaired; however, the failure persisted. The dealer had been contacted and confirmed that the VIN was not under recall. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 80,000.

The contact owns a 2018 Ford Fusion. The contact stated that the transmission was previously replaced twice. Additionally, the contact stated while driving 65 MPH, the vehicle stalled. The power train warning light was illuminated. The messages "Shift System Fault”, “See Owner’s Manual" and "Take Vehicle to Service Center Immediately" were displayed. The contact was able to veer to the side of the road. The vehicle was towed to the residence. The contact stated that while shifting to drive(D) or to reverse(R), the gear shifter independently shifted back to park(P). The dealer was notified of the failure and an appointment was scheduled for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure milage was approximately 89,000.

After reversing out of my driveway I could not get me fusion to go into drive. After getting the car back into my driveway my fusion starting putting the emergency brake on I would take it off and it would automatically put the parking brake back on. After looking at a video of problems with the shifter I popped my hood and found that the shift cable had come off. There is a recall on fusions for this issue but my year is not included.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the flex plate. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 22N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 116,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving at various speeds, the vehicle hesitated to shift between gear. The contact also stated that the vehicle automatically shifted into neutral and rolled backwards. The vehicle was towed to an independent mechanic who determined that the transmission shift cable bushing needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 164,000.

The flex plate is cracked at 87,000 miles and causing the vehicle to make a loud rattling noise near the bottom of the engine toward the back of the transmission. While driving the vehicle it drags while accelerating on turns and gives a hard shift in gears from park. The vehicle was inspected by Aamco transmission and several Ford dealers where i was told that this seems to be a common issue with the ford fusions according to several ford dealers but the ford manufacturer is refusing to place a recall for this matter. There is no warning indicating the issue is near or has occurred until the flex plate has already caused damage.

Upon shifting the gear to put the vehicle in park, the shifter automatically put itself in neutral and the parking brake enabled. A warning came on the dash, saying SHIFT SYS FAULT Service Required. A wrench light was illuminated as well. The bushing securing the shifting cable was gone, as if it crumbled to pieces. I have replaced this bushing a few times within the last year.