2012 Honda CR-V Engine

Subject: Engine Stalls Upon Acceleration from Stop - Near Collision ​Description: I am experiencing intermittent engine stalling on my 2012 Honda CR-V. The issue occurs specifically when attempting to accelerate from a complete stop (e.g., at stop signs or intersections). When I press the gas pedal to proceed, the engine unexpectedly shuts off and loses all motive power. ​On several occasions, the vehicle has stalled multiple times in succession before it would stay running. In one severe incident, I was attempting a right turn onto a busy road from a stop sign. The vehicle stalled mid-turn, leaving me stranded in the path of traffic. A vehicle approaching from behind nearly rear-ended me because I could not clear the intersection. ​There are no warning lights prior to the stall. This loss of power at intersections poses an immediate safety risk of collision. I suspect this may be related to the known VTC actuator/timing chain defect affecting this model year.

Upon cold start, the engine makes a loud knocking or rattling noise for several seconds, most noticeable after the vehicle has been sitting overnight. The noise seems to be coming from the timing area of the engine and has been identified by multiple mechanics as likely due to a faulty VTC (Variable Timing Control) actuator. This issue happens consistently during cold starts, then disappears once the engine warms up. There are no warning lights, diagnostic codes, or messages displayed on the dashboard when this occurs. The noise is loud enough to raise safety concerns, as it could indicate premature wear on internal components. I’m concerned that continued driving could lead to more serious engine damage. This problem has not been officially diagnosed by a dealership, but online forums and known service bulletins suggest this is a common issue with the 2012 Honda CR-V. From what I understand, the actuator allows oil to drain when the engine is off, causing a delay in oil pressure build-up and resulting in the knocking noise. This has not yet resulted in a breakdown, but the risk of future failure is concerning. I believe this should be further investigated due to the widespread nature of the problem and the potential long-term damage it could cause.

The 2012 Honda CRV with 107,000 miles was making noise on startup and first few minutes of running. This only happened a few times. No Engine light or oil light came on, but planned to bring to repair shop soon. Then the engine stalled driving on the highway. The car completely shutdown. When brought to Honda Dealer, they said it COMPLETELY ran out of oil and the engine, as well as many other components, were destroyed, quoting $11,0000 in repairs to put in another USED (not new) engine. The Oil had been replaced less than 7,000 miles prior to the incident with the recommended full synthetic (which Honda says should last 7,500 to 10,000 miles). Honda dealer said the engine had no compression, which means the piston rings were shot. This is the SAME EXACT issue that the 2008-2011 Accords/CRVs had, and Honda recognized it, extending the warranty to 125,000 on the engine. I requested assistance from Honda - they said NO - despite the fact THAT I HAVE OWNED 8 HONDAs in my lifetime. This will be the Last Honda I ever buy as even the 2018-2019 CRVS now have yet another oil consumption/dilution issue, and HONDA NO LONGER STANDS BY THEIR CUSTOMERS (because they can not afford to with their diminishing quality) !!

Faulty piston rings causing consistent low oil issues.

VTC actuator causing car to make grinding sound upon startup.The problem started 2 months after I bought the car from Brandon Honda, in FL. I drove it to Minnesota with no problem but as soon as I was there it was sputtering at every start up. This will be a costly repair, but due to previous litigation you would think it would be recalled. Many CRVs from the same year up north have the same problem. So It's pretty common. This could ruin the engine repair should offered on the faulty part that goes bad at lower temos. Just like the other common issue ( the AWD)

I am the original and only owner. Noticed grinding noise on engine startup, have researched the problem and narrowed it down to a VTC actuator defect on this vehicle. Honda has put out a TSB in the past on this issue. This failure has caused my timing belts to go bad and mechanics have told me I am at risk of having engine failure if this probem is not addressed. The manufacturer should resolve this issue nationwide. There have been reports of class action lawsuit in California and Illinois regarding this matter. Why do I as consumer have to shell out over $2000 to repair this mess which is a defect/fault of the manufacturer?

As nearly every Honda CR-V driver of this generation will state, the car always experienced a startling 1-2 second grind upon cold start up in a Northeast USA winter. With 198,000 miles, it began to do it at every start, especially the first start-up in the morning. I knew a while back that it was a faulty VTC actuator that Honda first knew about in the 2000s, but didn’t resolve until recently. A local Honda dealer confirmed this noise is the “normal” VTC actuator noise, and shrugged it off. They also shrugged it off when it was under an extended, covered warranty and I complained about it then. As many reading this likely know, the VTC actuator malfunction has numerous implications to the tensioner and the timing chain, among other components of the engine. Honda was allowed to brush this off because this was never considered a mandatory safety recall. And clearly, there is an issue because there is a class action lawsuit currently in California and Illinois - what about the other 48 states? Or those who are not the original owners? (I received this car in 2017 when my uncle, the original owner, passed). The VTC actuator failure is not a mild inconvenience. It can have catastrophic consequences and Honda uses it to charge customers thousands of dollars. The entire experience of myself and many have truly made me lose faith in whatever the NHTSA is supposed to do in order to ensure the safety of drivers.

Engine makes loud grinding noise at startup. Have been told it is likely the VTC Acctuator and/or an issue with the timing chain tensioner. The problem has gotten worse over time. Approximate date incident occurred is an estimate. I understand this is an issue with many of these vehicles and that there may even be a class action lawsuit filed. I am curious why this hasn't been deemed a recall item?

VTC actuator causing car to make grinding sound upon startup. I have determined that this is a KNOWN ISSUE with this make/model/year of Honda with litigation in California and Illinois. Left unfixed, my mechanic said this could lead to MUCH larger repairs down the road. This will directly affect the life of the car and can leave the driver stranded should the actuator fail completely due to the KNOWN faulty part.

TL* THE CONTACT OWNS A 2012 HONDA CR-V. THE CONTACT STATED WHILE STARTING THE VEHICLE, THE VEHICLE MADE A GRINDING NOISE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS NOT TAKEN TO THE LOCAL DEALER TO BE DIAGNOSED. THE MANUFACTURER WAS INFORMED OF FAILURE AND INFORMED THE CONTACT THAT SINCE THE VEHICLE WAS OUT OF WARRANTY, THERE WOULD BE NO ASSISTANCE PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 103,000.

GRINDING NOISE AT STARTUP. TOLD WAS VCT ISSUE BUT HUNDREDS OF OTHER COMPLAINTS FOR SAME ISSUE ON INTERNET.

REPORTED VTC ACTUATOR PROBLEM UNDER WARRANTY. HONDA REFUSED TO FIX. THEY ISSUED A TSB STATING IT WAS A NON-ISSUE. NOW, THE TIMING CHAIN IS STRETCHED, MECHANIC REPORTS THAT THE ENGINE IS DAMAGED BEYOND. METAL SHAVINGS ARE IN THE OIL FILTER, MAIN BEARINGS ARE WORN. ALL THIS BECAUSE OF A KNOWN DESIGN FLAW THAT THE MFG WAS UNWILLING TO REPAIR. *TR

VTC ACTUATOR GRINDING ON COLD START. REPORTED TO HONDA. PAID TO HAVE IT REPLACED OUT OF POCKET AT A COST OF $1443.83 ON 9/24/18 AT 111,863 MILES. AT 122,000 MILES STARTED HAVING HIGH OIL CONSUMPTION. AFTER SEVERAL MISDIAGNOSIS BY HARE HONDA, DETERMINED SAME ISSUE AS 2011 TSB A12-089 PROBLEM WITH STICKING PISTON RINGS. REQUIRES FULL ENGINE REBUILD QUOTED AT $2000. IF NOT FIXED CAN CAUSE ENGINE FAILURE.

2012 HONDA CR-V. WHEN THE VEHICLE IS STARTED, AN ABNORMAL LOUD RATTLING NOISE IS HEARD COMING FROM THE ENGINE. THERE ARE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HONDA CITY DEALER LOCATED IN LEVITOWN NY WHERE IT WAS DIAGNOSED THAT THE VTC ACTUATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT A COST OF $750 TO THE OWNER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT NO ASSISTANCE WAS PROVIDED TO REPAIR THE DEFECTIVE PART. THE NOISE APPEARED WHEN THE CAR WAS ONLY 3 YEARS OLD AND THE DEALER WAS CONTACTED BY PHONE BUT SAID THERE WAS NO PERMANENT FIX YET AND TO CALL BACK WHEN THE NOISE GOT LOUDER. THE FAILURE MILEAGE WAS APPROXIMATELY 51,000 WHICH WAS LESS THAN THE WARRANTY MILAGE OF 60,000. HONDA IS AWARE OF THIS DEFECTIVE PART THAT CAN CAUSE FURTHER ENGINE DAMAGE OR FAILURE BUT NO RECALL HAS BEEN ISSUED. POOR RESPONSE BY HONDA.

THERE'S A GRINDING NOISE THAT FOLLOWS THE START OF THE ENGINE. THIS ISSUE BEGAN 2 YEARS AGO DURING THE WINTER MONTHS. TOOK IT TO HONDA TO SEE WHAT WAS WRONG. THEY WEREN'T ABLE TO RECREATE THE SOUND AND SENT ME ON MY WAY. IT'S NOW DOING IT ALL OF THE TIME. I HAVEN'T TAKEN IT TO HONDA AGAIN, BUT I WILL WHEN I HAVE THE TIME AND MONEY TO FIX IT. INITIAL VIEWING OF THIS SITE SHOWS A LOT OF THE SAME ISSUE. HAVEN'T DONE ANY FURTHER RESEARCH TO SEE IF THE ISSUE HAS BEEN RESOLVED OR HANDLED BY HOND. I WILL ONCE I FINISH THIS POST. HOPEFULLY, HONDA IS DOING OR WILL DO THE RIGHT THING AND RECALL VEHICLES AFFECTED BY THIS ISSUE.

AFTER OWNING FOR 5 YEARS, DURING WINTER MONTHS A LOUD RATTLE SOUNDED EACH AND EVERY TIME THE MOTOR WAS TURNED ON. IT DID NOT MATTER IF ENGINE WAS COLD OR NOT. I TOOK TO DEALER WHO SAID FOR $699 THEY WOULD TRY AND FIX BUT NO GUARANTEES AND COULD STILL EXIST. I SPOKE TO DIFFERENT MECHANIC WHO SAID IF I CONTINUED WITHOUT GETTING IT REPAIRED, IT COULD RUIN THE ENGINE. I CALLED THE CORP OFFICE TO BE TOLD THAT THERE WAS NOT A RECALL BECAUSE THEY DID NOT HAVE A REPLACEMENT. I WAS FORCED TO SELL THE CAR. I AM LOOKING FOR COMPENSATION

FAULTY VTC ACTUATOR, GRINDING NOISE ON STARTING THE CAR EVERYDAY IN THE MORNINGS. DEALER HAVE A $600.00 ESTIMATE TO HAVE IT FIXED AND NOT COVERED UNDER STANDARD WARRANTY. HONDA IS AWARE OF THIS ISSUE AND NO RECALL HAS BEEN ISSUED.

GRINDING NOISE WHEN COLD STARTING AND IT HAS BEGUN TO STALL THE ENGINE.

TL* THE CONTACT OWNS A 2012 HONDA CR-V. WHEN THE VEHICLE WAS STARTED, AN ABNORMAL NOISE WAS HEARD COMING FROM THE ENGINE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO GWINNETT PLACE HONDA (3325 SATELLITE BLVD, DULUTH, GA 30096, (678) 274-6206) WHERE IT WAS DIAGNOSED THAT THE VTC ACTUATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 76,000.

PLEASE RESEARCH THIS ISSUE WITH 2012 HONDA CR-V'S AS I AM NOT THE ONLY ONE WITH THIS ISSUE AND I BELIEVE IT'S A SERIOUS SAFETY ISSUE: THE VEHICLE SHAKES, VIBRATES OR WOBBLES WHEN ACCELERATING IN LOW GEARS. IT STOPS WHEN EASING UP ON THE GAS PEDAL. IT TYPICALLY OCCURS WHEN THE VEHICLE SHIFTS (AUTOMATIC TRANSMISSION) BETWEEN THE 1ST AND 2ND GEARS. THE WHOLE CAR SHAKES. THE ONLY WAY TO STOP IT IS BY REMOVING FOOT FROM GAS PEDAL OR ACCELERATING CAR QUICKLY TO HIGHER SPEED. THE ISSUE AFFECTS THE ABILITY TO SAFELY ACCELERATE TO PROPER SPEED. BEGINS WHEN ACCELERATING FROM A STOPPED POSITION ALL THE WAY UP UNTIL CAR REACHES ABOUT 40-45 MILES PER HOUR. OCCURS ON ALL TYPES OF ROAD CONDITIONS BUT IS VERY PRONOUNCED WHEN DRIVING ON A FLAT SURFACE. I HAVE TAKEN MY VEHICLE TO BE SERVICED AT THE HONDA OF THE AVENUES AND I WAS TOLD IT WAS RESOLVED. IT HASN'T BEEN RESOLVED AND I HAVE BEEN TRAVELING SO I HAVEN'T HAD THE CHANCE TO TAKE IT BACK. I AM UP TO DATE WITH ALL MY OIL CHANGES AND MAINTENANCE. I SEE THAT I AM NOT THE ONLY ONE WITH THIS ISSUE WITH MY 2012 HONDA CRV AS OTHERS WITH THE SAME VEHICLE ARE COMPLAINING ONLINE. THIS SHOULD BE PART OF A RECALL SERVICE.

ENGINE RATTLES AT COLD START-UP - VTC ACTUATOR NEEDS REPLACEMENT. THE HONDA DEALER (CRISWELL HONDA, GERMANTOWN MD) DOING THE MAINTENANCE SAYS THAT I HAVE GONE PAST THE WARRANTY. BUT I HAVE BEEN THERE MULTIPLE TIMES FOR SERVICE BEFORE AND MENTIONED ABOUT THE ISSUE. THEY DID NOT FIX IT OR EXPLAINED TO ME THE ISSUES. THEY ARE CHARGING ME $800 NOW FOR THIS. BASED ON CURRENT SEARCH IN GOOGLE, THIS IS WHAT I FIND. PLEASE HELP HONDA TSB NUMBER:A09-010.V4 NHTSA NUMBER:10087883TSB DATE:MARCH 17, 2016 FAILING COMPONENT: ENGINE (PWS) SUMMARY: SERVICE BULLETIN - REPLACE THE VTC ACTUATOR IF THE ENGINE RATTLES LOUDLY FOR 2 SECONDS DURING COLD START-UP.

RATTLE NOISE ON COLD START UP. VTC ACTUATOR REPLACED UNDER WARRANTY AND NOW SAME PROBLEM AGAIN AFTER 10;000 MILES. FROM MY READING AND SPEAKING TO SEVERAL AUTO MECHANICS, THIS IS A COMMON PROBLEM WITH THIS MODEL OF CAR AND IT SEEMS LIKE HONDA OF AMERICA HAS NOT TAKEN RESPONSIBILITY FOR ADDRESSING THIS PROBLEM ADEQUATELY. I THINK A RECALL OF THIS ENGINE OR AN EXTENSION OF THE WARRANTY SHOULD BE REQUIRED.

ENGINE RATTLES AT COLD START UP. PER SERVICE BULLETIN THE VTC ACTUATOR IS FAULTY AND NEEDS TO BE REPLACED WITH AN UPGRADED PART. THIS IS THE SECOND TIME I WILL NEED TO HAVE IT REPLACED. I SHOULDN'T HAVE TO PAY FOR THIS REPAIR AGAIN.

2012 HONDA CR-V VTC ACTUATOR RECALL.....WHENEVER I START MY CAR I HEAR A GRINDING NOISE WHICH I HAVE BEEN TOLD IS THE VTC ACTUATOR. THE NOISE IS VERY ANNOYING IT MAKES LOUD LOUD NOISE EVERY TIME THE CAR IS STARTED.

THE VTC IS MAKING A RATTLING NOISE ON A COLD START UP. THIS STARTED OUT OF NOWHERE AND HAS NOT GONE AWAY. MY CAR IS PARKED IN A GARAGE AT HOME AND IS PARKED OUTSIDE AT WORK BUT WILL DO THE SAME NO MATTER WHAT.