2018 Ford Fusion Engine
Owner-reported problems and safety issues filed with NHTSA. Review common failures, severity levels, and complaint trends over time.
Complaint Timeline
Chronological view of owner reports
While operating my 2018 Ford Fusion, the vehicle began experiencing internal coolant loss resulting in engine misfires, rough running, and white exhaust smoke. The coolant intrusion caused engine failure and loss of reliability. This condition creates a safety risk, as it can lead to loss of power while driving, hesitation, and the possibility of engine shutdown. The defect occurred without warning and is consistent with widespread reports involving Ford EcoBoost engines. This issue is not related to maintenance or normal wear and tear but is a known design defect acknowledged through service bulletins and consumer litigation. Repair requires full engine replacement.
My car started rumbling and flashing the check engine light. I took it to the mechanic the next day, they tell me to contact Ford because of CSP 21N12 due to my spark plugs having coolant leaking on them and in cylinder, it was misfiring. They tell me the vehicle is unsafe to drive. I call Ford and they say theres nothing they can do. Im screwed out of a car because they closed the CSP's nov 2022 and i just got the car last year pre owned.
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle started shuddering violently, hesitated, and failed to accelerate to approximately 35 MPH. The check engine warning light was flashing. The contact related the failure to the Customer Satisfaction Program: 21N12. The vehicle was towed to the local dealer, where it was diagnosed with coolant intrusion into the cylinders. The dealer informed the contact that the engine small block needed to be replaced, but a full engine replacement was recommended. The vehicle was not repaired. The manufacturer was contacted and filed a complaint. The manufacturer advised the contact that a future report would be issued. The failure mileage was approximately 100,000.
Coolant is leaking into the cylinders and causing overheating and no start.
The contact owns a 2018 Ford Fusion. The contact stated that the low coolant warning light had illuminated prematurely. Upon inspecting the vehicle, the contact was unable to find a coolant leak. Additionally, the contact stated that the vehicle overheated while driving, which required the contact to pull over temporarily and to resume driving after the vehicle had cooled down. The vehicle was taken to a certified mechanic, where it was diagnosed that there was coolant intrusion into the engine, which caused the engine to slowly fail. The vehicle was not repaired. The dealer was notified of the failure. The contact related the failure to an unknown recall. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was approximately 150,000.
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was running rough, jerking, and shaking. The transmission and coolant temperature warning lights were illuminated. The message "Engine Overheating - Reduced Power" was displayed, and the vehicle went into LIMP Mode. The contact pulled over and had the vehicle towed to the residence. The vehicle was later towed to an independent mechanic, who determined that there was coolant intrusion in the engine, a blown head gasket, and a cracked engine block. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 148,000.
Engine replaced due to flaw in design. I had my 60,000-mile service done and after it was completed, I started having serious issues with my vehicle. Kept getting check engine light cylinder 2 misfire. I took my Fusion back to the dealership, and they advised me that my engine had to be replaced. Apparently when they put my vehicle under pressure during the service it caused the coolant to leak into my engine. I have researched this and found many complaints with the same problem. Unfortunately, the owners of the other Fusions (like me) found out their vehicle was no longer under warranty, and they had to foot the entire bill. Luckly for me, I had purchased the Ford Extended Warranty, and my out-pocket pocket is $100. I was told by the dealership that Ford is aware of this issue but has not issued a recall. My service advisor was absolutely shocked when Ford authorized the necessary repairs in a couple hours berceuse it normally takes a few days to get authorization. I have owned this car since it was new and have always kept up with the required maintenance. They gave me a rental vehicle and said it would be about 7 days before the repairs are completed.
The contact owns a 2018 Ford Fusion. The contact stated that while starting the vehicle, the vehicle shuddered with white smoke coming from the exhaust pipe. The check engine warning light was illuminated. The failure had occurred on several occasions. The vehicle was taken to an independent mechanic where it was diagnosed with coolant leak into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and filed a complaint. The vehicle remained at residence unrepaired. The approximate failure mileage was 140,000.
The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine with white smoke coming from the exhaust system, with the check engine warning light illuminated. Additionally, the message “Service Vehicle Soon” was displayed. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the engine was faulty due to coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 84,112.
The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, the vehicle started shuddering. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that there was coolant leaking into the cylinder. The mechanic informed the contact that the engine needed to be replaced. The contact called the local dealer for parts; however, the vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not under recall for the failure. The failure mileage was approximately 91,000.
Engine overheated multiple times during high speed/high traffic situations due to a design flaw within the engine. Ford was aware of these issues in this engine for years and still knowingly sold them to American consumers, myself included. This is wrong and erodes the trust myself and others have in the American auto industry.
The contact owns a 2018 Ford Fusion. The contact stated that after the engine was replaced, there was an abnormally loud banging sound coming from the engine compartment. The vehicle was taken back to the local dealer, who diagnosed the vehicle with a cracked engine flex plate. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 59,851.
The contact's son owns a 2018 Ford Fusion. The contact's son stated while driving at an undisclosed speed, the vehicle shuddered and white smoke emitted from the exhaust pipe. The check engine warning light was illuminated. The failure occurred on several different occasions and the coolant level was abnormally low. The vehicle was not taken to a dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.
My Vehicle was found to have a coolant intrusion. There is a know defect on these vehicles (1.5 / 2L) Ford engine. There was a hairline crack in 2 of the cylinders, which causes coolant to leak thoroughout the engine. My safety was put at risk as this issue causes the vehicles engine to overheat at an unsafe rate. 2 separate dealers found this issue CBA and Autonation Ford. Fidelity Warranty Services inspected the vehicle to see what would be covered. they appeared about 2 weeks prior but would disappear. It finally came back but was extremely repetitive
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle briefly began to shake violently before returning to normal functionality. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion into various cylinders had resulted in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 130,000.
Engine light came on got it diagnosed said it was misfiring in cylinder 2. spark plugs and coil needed to be changed. Changed all spark plugs and coil and the engine light is still on and saying the same thing. Doesn’t crank right. Coolant going into engine. My vehicle only has 32,000 miles. Seems to be a know problem but ford will not do anything. Saying I need a new motor.
The contact owns a 2018 Ford Fusion. The contact stated that while driving at various speeds, there was white smoke coming from the rear exhaust. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed with coolant intrusion into cylinder #3, low coolant, and an overheated engine. The vehicle was not repaired due to the cost. The contact related the failure to TSB: 19-2208. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 76,000.
Engine failure due to coolant leaking into cylinders. This is a known issue. Also Ford has issued a bulletin on this. but no recall yet! I still own 10k on my car and now a blown engine.
Vehicle has a loss of coolant but no visible leaks think may be due to a engine leak.
The engine cooling system and engine block failed due to coolant intrusion into the engine cylinders. This issue has been diagnosed by an independent mechanic and is available for inspection upon request. Yes, the problem has been confirmed by an independent service center, which diagnosed coolant intrusion into the engine block, a known issue on this engine. The shop recommended full engine replacement and stated this is a common failure in this vehicle. Not yet by the manufacturer, police, or insurance. The issue has only been inspected by a certified independent mechanic. Yes, a check engine light appeared along with a coolant temperature warning message. The vehicle also began to idle roughly, produce heavy exhaust, and consume coolant. These symptoms began appearing shortly before diagnosis in June 2025. I own a 2018 Ford Fusion with a 2.0L EcoBoost engine. The vehicle recently began experiencing coolant loss, heavy exhaust, and check engine alerts. A certified mechanic confirmed that coolant has intruded into the engine block, causing internal misfires and risk of major engine failure. I was told this is a common and well-documented issue with this engine design, yet there has been no official recall from Ford despite similar problems affecting other models (referenced in Ford TSB 19-2208). The mechanic has recommended a full engine replacement with an estimated cost of $13,000. This is a serious safety concern, as the engine can overheat, stall, or seize while driving.
2018 fusion AWD Titanium, less than 70,000 miles, no warning, no reason. Driving 70mph on interstate when low coolant light comes on, check engine light comes on, car starts losing power and running rough, finally full stall in middle of freeway with catastrophic engine failure due to coolant leak and faulty design. Car was not low on any fluids as they were checked everyday before it was driven. This could have gotten me and my children killed and quite frankly I dont know how it didn't. I bought this car with 44k miles on it. Drove it less than 30k miles and had catastrophic engine failure. This was AFTER I had it in the shop several times for crank shaft position sensor, wouldn't start, and several other problems. The car was taken care of and in immaculate condition. Ford knew these engines would fail prematurely and continued to manufacture them and sell them.
The contact owns a 2018 Ford Fusion. The contact stated while the vehicle was parked, the vehicle shuddered. The contact stated that the check engine warning light was illuminated, and the message "Coolant Overheating" was displayed on the instrument panel. The failure had occurred on several occasions. The vehicle was taken to a dealer where it was diagnosed and determined that there was coolant intrusion into the cylinders, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 90,000.
The contact owns a 2018 Ford Fusion. The contact stated that while driving 5 MPH, the contact heard a sound like running water coming from the engine. The contact stated that the check engine warning light was illuminated. An independent mechanic was contacted. The vehicle was taken to the independent mechanic, where it was diagnosed that there was coolant leaking into the engine, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact related to the failure of the Customer Satisfaction Program: 19B37 (Engine - Powertrain Control Module Reprogramming). The contact was transferred to the NHTSA Hotline to report the failure. The approximate failure mileage was 102,000.
The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the engine overheated with the check engine warning light illuminated. The contact stated that the message that the engine was overheating was illuminated. The vehicle was restarted after the contact added coolant to the reservoir. The contact stated that after adding coolant to the reservoir, the failure recurred. The vehicle was taken to an independent mechanic, where it was diagnosed that coolant had leaked into the cylinders, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired, and the contact was referred to the dealer for further assistance. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 155,000.
The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 45 MPH, the message "Engine Overheating" was displayed on the instrument panel. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that there was internal coolant intrusion into the cylinders, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 86,000.
Trend Over Time
Complaints by year
Other Issues
Common problems reported
Quick Summary
The 2018 Ford Fusion has 167 Engine complaints on file. Review the timeline above for detailed owner experiences.